Cat Electronic Technician 2014A v1.0 Product Status Report 10/23/2016 9:09 AM

Transcription

1 Cat Electronic Technician 2014A v1.0 Product Status Report 10/23/2016 9:09 AM Product Status Report Parameter Engine Serial Number Equipment ID Comments Value DSE M-9-P RUNNING OF NOS.3 ENGINE AFTER OVERHAUL ON HRS ON OCEAN GLORY C18 Marine Genset #1 (DSE00164) Parameter Value Equipment ID 78M-9-P Engine Serial Number DSE00164 ECM Serial Number JV Software Group Part Number Software Group Release Date OCT13 Software Group Description C18-MarAuxACERT-A4 Logged Diagnostic Codes [Diagnostic Clock = hours] - C18 Marine Genset #1 (DSE00164) Code Description Occ. First Last 91-8 Throttle Position Sensor : Abnormal Frequency, Pulse Width, or Period Logged Event Codes [Diagnostic Clock = hours] - C18 Marine Genset #1 (DSE00164) Code Description Occ. First Last E096 (1) High Fuel Pressure E105 (2) Turbocharger Turbine Inlet Air High E190 (1) Engine Overspeed Warning E190 (3) Engine Overspeed Warning E198 (1) Low Fuel Pressure E552 (1) Low Aftercooler Coolant Level Active Diagnostic Codes - C18 Marine Genset #1 (DSE00164) Code No Active Codes Description Active Event Codes - C18 Marine Genset #1 (DSE00164) Code Description

2 No Active Events Current Totals - C18 Marine Genset #1 (DSE00164) Description Value Unit Total Time 4712 hours Total Fuel gal Average Fuel Rate Based Percent Engine Load Factor 25 % Configuration - C18 Marine Genset #1 (DSE00164) Description Value Unit Equipment ID 78M-9-P Engine Serial Number DSE00164 ECM Serial Number JV Software Group Part Number Software Group Release Date OCT13 Software Group Description C18-MarAuxACERT-A4 Rating Number 1 Rated Frequency 60 Hz Rated Engine Speed 1800 rpm Rated Power 738 hp at 1800 rpm Rating Configuration Low Emissions Test Spec 0K0000 Engine Location Engine #1 Engine Acceleration Rate 500 rpm/s Crank Terminate RPM 400 rpm Low Idle Speed 1200 rpm Engine Speed Droop 0.0 % Droop/Isochronous Switch Enable Enabled Droop Mode Selection Externally Requested Isochronous Remote Throttle Control Ramp Rate 10 rpm/s Desired Speed Input Configuration PWM Secondary Desired Speed Input PWM Configuration Emergency Shutdown Override Input Switch to Ground Configuration Emergency Shutdown Override Switch Not Installed Remote Throttle Control Install Installed Coolant Level Sensor Installed Aftercooler Coolant Level Sensor Installed Unfiltered Engine Oil Pressure Sensor Not Installed Unfiltered Fuel Pressure Sensor Installation Not Installed Status Engine Coolant Pressure Sensor Not Installed

3 Exhaust Sensor Installation Not Installed Status Engine Oil Sensor Installation Not Installed Status Engine Oil Level Sensor Not Installed High Exhaust Warning Disabled System Enable Status Engine Oil Capacity 19.0 gal Maintenance Indicator Mode Off PM1 Interval 0 gal Governor Gain Factor # Governor Minimum Stability Factor # Governor Maximum Stability Factor # FLS 24 FTS 0 Total Tattletale 14 Lifetime: Time vs Engine Coolant - C18 Marine Genset #1 (DSE00164) Engine Coolant ( hours % Deg F ) < > Lifetime: Time vs Inlet Air - C18 Marine Genset #1 (DSE00164) Inlet Air ( Deg F ) hours % <

4 > Lifetime: Time vs Boost Pressure - C18 Marine Genset #1 (DSE00164) Boost Pressure( psi ) hours % < > Lifetime: Time vs Engine Speed And Engine Load Factor - C18 Marine Genset #1 (DSE00164) rpm < >2300 Total % < > Total Lifetime: Total Occurrences vs Engine Speed - C18 Marine Genset #1 (DSE00164) Engine Speed( rpm ) % < > Lifetime: Time vs Turbo Inlet And Inlet Air - C18 Marine Genset #1

5 (DSE00164) Deg F < >140 Total Deg F < > Total Lifetime: Time vs Fuel Pressure - C18 Marine Genset #1 (DSE00164) Fuel Pressure( psi ) hours % < > Injector Trim Calibration - C18 Marine Genset #1 (DSE00164) Injector Serial Number File Version Injector A F 0 Injector A F1 0 Injector A A5 0 Injector A AD 0 Injector A AD 0 Injector A C1 0 Monitoring System - C18 Marine Genset #1 (DSE00164) Description State Trip Point Delay Time Engine Overspeed Least Severe (1) Always On 1980 rpm 0 sec Most Severe (3) Always On 2070 rpm 0 sec High Engine Coolant Least Severe (1) Always On 216 Deg F 30 sec Moderate Severity (2) On 225 Deg F 30 sec Most Severe (3) Off 230 Deg F 30 sec

6 High Engine Inlet Air Least Severe (1) On Deg F 30 sec Moderate Severity (2) Off Deg F 30 sec High Engine Oil Least Severe (1) On 221 Deg F 5 sec Moderate Severity (2) Off 239 Deg F 15 sec Most Severe (3) Off 239 Deg F 30 sec High Exhaust Least Severe (1) Off 1274 Deg F 5 sec High Fuel Filter Restriction Pressure Least Severe (1) On 20 psi 30 sec High Fuel Pressure Least Severe (1) On None 2 sec Moderate Severity (2) On None 30 sec Most Severe (3) Off None 30 sec High Fuel Least Severe (1) Always On Deg F 30 sec Moderate Severity (2) Off Deg F 30 sec Most Severe (3) Off Deg F 30 sec High Oil Filter Differential Pressure Least Severe (1) On 16 psi 30 sec Low Aftercooler Coolant Level Least Severe (1) On None 30 sec Moderate Severity (2) Off None 30 sec Most Severe (3) Off None 30 sec Low Coolant Level Least Severe (1) On None 30 sec Moderate Severity (2) Off None 30 sec Low Engine Coolant Pressure Least Severe (1) On None 10 sec Moderate Severity (2) On None 130 sec Low Engine Oil Level Least Severe (1) On None 30 sec Moderate Severity (2) Off None 30 sec Low Engine Oil Pressure Least Severe (1) Always On None 8 sec Moderate Severity (2) On None 8 sec Most Severe (3) Off None 4 sec Low Fuel Level Least Severe (1) Off 13 % 300 sec Low Fuel Pressure Least Severe (1) On None 2 sec

7 Moderate Severity (2) Off None 30 sec Most Severe (3) Off None 30 sec Bridge Color MPD -Starbrd Parameter Value ECM Part Number ECM Serial Number 1294G001MU Software Group Part Number Software Group Release Date Software Group Description Configuration - Bridge Color MPD -Starbrd Description Value Unit Display Location Bridge Engine Location Starboard