Advances in In-Plant Treatment of Taste-and-Odor Compounds

Size: px

Start display at page:

Download "Advances in In-Plant Treatment of Taste-and-Odor Compounds"

Julian Andrews
5 years ago
Views:

PhD Tsinghua University, China 10 th IWA Symposium on

1 Advances in In-Plant Treatment of Taste-and-Odor Compounds Djanette Khiari, PhD Water Research Foundation, USA Chao Chen, PhD Tsinghua University, China 10 th IWA Symposium on Off-Flavours in the Aquatic Environment, Oct.27 Nov 1, 2013 NCKU Tainan, Taiwan

2 Important References Identification and Treatment of Tastes and Odors in Drinking Water (AwwaRF, 1987) Advances in Taste-and-Odor Treatment and Control (AwwaRF, 1995)

3 Treatment Options 1. Oxidation 1. Conventional Cl2, ClO2, KMnO4 2. Advanced O3, O3/H2O2, UV/H2O2 2. Adsorption 1. Powdered Activated Carbon (PAC) 2. Granular Activated Carbon (GAC) 3. Biological Treatment 1. Conventional Filter Media 2. Biological Activated Carbon (BAC) 4. Others 1. Membranes 2. Mixed

4 What, Why, When? Regulations Consumer perception Severity, duration, and frequency of the problem Risk/risk trade-offs Site and treatment specificity Performance Cost (capital and operations)

5 Overview of Treatment Technologies Geosmin and MIB Treatment Approx. Max Conc. (ng/l) Episode Duration Capital Cost O&M Cost Usage for T&O (%) Cl 2 /ClO 2 /KMnO 4 < 20 Short/Long $ $ 18 PAC < 50 Short $ $$ 69 Biotreatment <50 Long $-$$ $ Ozone/H 2 O Short/Long $$-$$$ $-$$$ UV/H 2 O Short $$-$$$ $$-$$$ GAC Long $$-$$$ $-$$$ 5 GAC / Multiple Barrier > 100 Short $$$ $-$$ Multiple Barrier > 100 Long $$$ $$$ Corwin & Summers, 2011

6 Adsorption Source Flash Mix Clarifiers Filters Storage Impacts Form Capital Application Handling Selection Good removal of TCA, geosmin, MIB, IPMP Competition (TOC, DOC, NOM, BOM, organics) Other treatment chem (oxidants, coagulants, ph) Dose Contact time PAC GAC Low Moderate 2011 Water Research Flexible (when, where, Foundation. ALL RIGHTS Fixed barrier (can support type, how much) biological activity) RESERVED. Messy Easier $/unit removal - jar test $/unit removal - RSSCT

7 Powdered Activated Carbon (PAC) Dose (mg/l) Contact Time (min) Removal (%) Limitations PAC > 95 Feed Rate Oxidant compatibility Performance Drivers for PAC 1. Influent TOC concentration 2. Influent concentration and treatment objective 3. PAC dose 4. PAC type (base material) 5. Contact time and mixing

8 Powdered Activated Carbon (PAC) Influent TOC Concentration and Contact Time Cho and Summers, 2007

9 Powdered Activated Carbon (PAC) PAC Dose and Type MIB C/C bituminous PAC lignite PAC PAC dose (mg/l) wood PAC

10 Powdered Activated Carbon (PAC) Influent Concentration and Treatment Objective MIB (ng/l) C 0 =50 ng/l C 0 =20 ng/l PAC dose (mg/l) MIB C/C PAC dose (mg/l)

11 Superfine Powdered Activated Carbon (SPAC) Submicron-sized activated carbon: obtained by wet-milling commercially available activated carbon

12 MIB Removal (S-)PAC Dose = 15 mg/l Initial MIB Conc. = 100 ng/l Overall, smaller as-received PACs did not perform better than traditional PACs Superfine forms of PAC A and C achieved >89% MIB removal Dunn et al, 2010

13 MIB Removal equilibrium conditions (S-)PAC Dose = 15 mg/l Initial MIB Conc. = 100 ng/l Grinding as-received PAC to a finer particle size enhanced adsorption kinetics did not increase equilibrium uptake capacity for MIB S-PACs would be beneficial for MIB removal at short contact times Dunn et al, 2010

14 CCR MIB Removal (S-)PAC Dose = 15 mg/l Initial MIB Conc. = 100 ng/l LM Similar MIB removal trends in CCR and LM waters with S-PAC achieving higher MIB removal than PACs Decreased MIB removal in LM water possibly due to higher adsorption competition between NOM and MIB (higher NOM concentration in LM water) Dunn et al, 2010

15 Granular Activated Carbon (GAC) Application Filter Adsorber Post-Filter Adsorber EBCT (min) Removal (%) Use Rate (lb/1,000 gal) Media size 2-10 > x30 ES= 0.90 mm 5-30 > x40 ES= 0.65 mm Limitations Oxidant compatibility Media replacements are more difficult May need sand layer Backwashed Cost/space/hydraulic head Oxidant compatibility

16 Granular Activated Carbon (GAC) Performance Drivers 1. Influent TOC concentration 2. Influent concentration & treatment objective 3. Design and operation strategy 4. GAC type

17 Granular Activated Carbon (GAC) Operation Strategy Operation Advantages Disadvantages Continuous DBP formation control Lower Cl 2 demand 0.5 log Crypto credit (PFA only) Reduced TO adsorption capacity* * can be offset by GAC change-out prior to episode Intermittent Maximum TO adsorption capacity Large capital investment for intermittent use Biological Possible removal by both adsorption and biodegradation? Possible bio-regeneration of adsorption capacity?? More frequent backwashes Underdrain clogging? Possibility of higher HPC counts in finished water? Corwin and Summers, 2011

18 Oxidation Source Flash Mix Clarifiers Filters Storage Distribution Permanganate Chlorine Chloramines Chlorine dioxide Ozone UV Advanced oxidation (O 3 /H 2 O 2, UV/H 2 O 2 )

19 Permanganate (MnO 4- ) Source Flash Mix Clarifiers Filters Storage Distribution Fishy, grassy, cucumber Reduces Chlorine demand Reduces AC demand THMs Colored water Adsorption (???)_

20 Chlorine Source Flash Mix Clarifiers Filters Storage Distribution Marshy/Swampy/Septic/Sulfurous/Fishy Disinfection Algae control Chlorinous Medicinal Biofilm control DBP formation

21 Chlorine Dioxide (ClO 2 ) Source Flash Mix Clarifiers Filters Storage Distribution Marshy/Swampy/Septic/Sulfurous/Medicinal Disinfection and algae control Fe and Mn control Kerosene Cat urine ClO 2- /ClO 3- formation

22 Advanced Oxidation Processes (AOPs) An effective process for disinfection and chemical oxidation AOPs work by creating hydroxyl radicals ( OH) Complex chemistry Several Technologies UV/H 2 O 2, UV/O 3, UV/HOCl, etc. Ozone/H 2 O 2, Ozone/NOM, Ozone/pH

23 Ozone/AOPs Pre-Ozone Basin Flash Mix Clarifiers Inter-Ozone Basin Filters Post-Ozone Basin Storage Higher Dose Unstable Residual Easier Hydraulics Fragrant/Sweet Medicinal Lower Dose Stable Residual Difficult Hydraulics Lowest Dose Stable Residual AOC BrO 3- formation

24 Ozone Oxidation of MIB and Geosmin Ozone is effective for MIB and geosmin Direct ozonation is very slow for oxidizing MIB and geosmin But OH radical is quite effective Direct ozonation better for toxins Compound k O3 (M -1 s -1 ) k OH (M -1 s -1 ) MIB N/A 8.2x10 9 Geosmin N/A 1.4x10 10 Observed MIB and Geosmin ozone oxidation a result of Advanced Oxidation (AOP)

25 Ultraviolet (UV) Source Flash Mix Clarifiers Filters Storage Distribution MTBE (90%) Geosmin/MIB (90%) NDMA (90%) Virus (2-log) Crypto. (>2-log) ,000 10,000 Applied UV Dose (mj/cm 2 )

26 UV AOP for Taste and Odor UV Photolysis UV Advanced Oxidation Rosenfeldt and Linden, 2005

27 AOP performance Ozone + Peroxide AOP UV + Peroxide AOP Extra 30% oxidation AWWARF, 2005 Rosenfeldt and Linden, 2004

28 Biological Filtration Principle: Odorants at low concentrations are utilized by microorganisms as secondary substrates when the biodegradable organic matter is sufficient to serve as the primary substrate. Biotreatment Conventional Media Biological Activated Carbon (BAC) in FA Contact Time (min) Corwin and Summers, 2011 Acclimation Period Removal (%) Limitations 5 10 > 4 months 30 - > 95 Temperature Substrate availability Influent concentration fluctuations 5 10 > 4 months 60 - > 95 Temperature Substrate availability

29 Pilot Testing 100% 90% 80% 70% Spiked Influent MIB = ng/l MDL for MIB = 1.9 ng/l EBCT 3.3 min of A/S (Control) EBCT 3.3 min of A/S EBCT 3.3 min of GAC-B/S EBCT 3.3 min of GAC-L EBCT 5.2 min of GAC-B MIB Removal 60% 50% 40% 30% 20% 10% 0% Settled water (AWWARF, 2005 Westerhoff) Ozonated Settled Water Elevated TOC Water Ozonated Elevated TOC Water

30 Pilot Testing Biofilters receiving 4 different feed waters, biologically active carbon (GAC) removed more MIB and geosmin) than GAC/sand or anthracite/sand biofilter The control anthracite/sand (A/S) biofilter received chlorinated water and achieved minimal MIB degradation. Longer EBCCT improved removal

31 Pilot Testing Pilot tests required at least 2 months of constant MIB exposure to become acclimated and biologically stable. Longer EBCTs and higher temperatures improved MIB degradation Filter biomass density was a good indicator for MIB removal in some pilot tests. More biomass equated to improved removal. Backwashing practices affected biomass density, with more benefit of using non-chlorinated water

32 Membrane Treatment Removal by Size and Charge Membrane effective pore size Membrane surface charge (Zeta potential) Compound charge (pka) Charges depend on water ph Microfiltration and Ultrafiltration Particle removal membranes Limited removal by charge repulsion Reverse osmosis may remove minerals and organics producing unpalatable water Highly corrosive to metal plumbing

33 Courtesy of Gayle Newcombe

34 Caution!!! Algae vs. Algal Metabolites Algal metabolites can be: Intracellular: Contained within the cell Extracellular : Dissolved (extracellular) Cells can be removed by physical processes (relatively easy) Extracellular, dissolved metabolites can be removed by physical, chemical or biological processes (not so easy)

dimensions defined by the ring size of the aperture 10 ring" is a closed loop built from

35 Zeolites Primary building blocks are TO 4 tetrahedra (T is Si 4+ or Al 3+ ) linked via their oxygen atoms to other tetrahedra Structural subunits form crystalline framework Pore dimensions defined by the ring size of the aperture 10 ring" is a closed loop built from 10 tetrahedrally coordinated Si 4+ (or Al 3+ ) atoms and 10 oxygen atoms : Si 4+ or Al 3+ :Oxygen

36 Zeolite framework types Silicalite framework type: Pore dimensions: 0.53 x 0.56 nm and 0.51 x 0.55 nm Beta framework type: 0.76 x 0.64 nm Mordenite framework type: 0.65 x 0.70 nm Y framework type: 0.74 nm diameter windows 1.3 nm supercages Source:

37 Zeolites SiO 2 /Al 2 O 3 ratio the determines hydrophobicity and acidity of the zeolite low SiO 2 /Al 2 O 3 negative framework charge hydrophilic character not effective for the adsorption of organic contaminants but suitable for cation exchange more acidity suitable for surface reactions high SiO 2 /Al 2 O 3 low negative or neutral framework charge hydrophobic character suitable for the adsorption of organic contaminants less acidity not very reactive

38 Experiments with 14 C-MIB assess overall removal of 14 C from solution but do not provide information about the reactive removal of MIB Experiments with 12 C-MIB were conducted to specifically track MIB removal

39 C-12 C-14 H-Mordenite-90A qe, µg/g 10 qe, µg/g Clearly, 12 C data differed from the C e, ng/l 14 C data when testing mordenite H-Mordenite-90 H-Mordenite C-12 zeolites!! C C e, ng/l qe, µg/g C-12 C C e, ng/l Yuncu and Knappe, WaterRF 2005

2-methyl-2- bornene (2M2B) H + H + H + H + Acidic zeolite surface 2-

40 Discrepancies between 14 C-MIB and 12 C-MIB data may suggest that a reaction removal mechanism other than adsorption contributes to MIB removal MIB 2-methyl-2- bornene (2M2B) H + H + H + H + Acidic zeolite surface 2- methylenebornan e (2MB) 1-methylcamphene (1MC) Yuncu and Knappe, WaterRF 2005 Non-odorous products

Assess then Address: Evaluating Contaminant Sources and Selecting Viable Treatment Barriers for the Clapper Road WTP

Assess then Address: Evaluating Contaminant Sources and Selecting Viable Treatment Barriers for the Clapper Road WTP April 14, 2016 Marc Santos, PE Hazen and Sawyer Agenda Background Objectives/Strategy