modeling of equilibrium and dynamic multi-component adsorption in a two-layered fixed bed for purification of hydrogen from methane reforming products
|
|
- Godfrey Singleton
- 5 years ago
- Views:
Transcription
1 modelng of equlbrum and dynamc mult-component adsorpton n a two-layered fxed bed for purfcaton of hydrogen from methane reformng products Mohammad A. Ebrahm, Mahmood R. G. Arsalan, Shohreh Fatem * Laboratory of Adsorpton Processes, Department of Chemcal Engneerng, Faculty of Engneerng, Unversty of Tehran. * P.O.Box-11155/4563, Enghelab Ave. Tehran, Iran, Fax: ( ) , Emal: shfatem@ut.ac.r Adsorpton s one of the most common ndustral processes for Hydrogen purfcaton. Layered bed columns wth dfferent adsorbents consstng actvated carbon and zeolte materals are used for effcent adsorpton of lght gases such as, CO 2, CO, N 2 and CH 4, n methane reformng gas product and purfcaton of hydrogen wth hgh qualty. A dynamc mult-component adsorpton model was developed n a fxed bed of ndustral scale contanng two layer of adsorbent. Lumped knetc model wth lnear drvng force between sold phase concentraton and ts equlbrum condton was assumed for mass transfer between the gas and sold phase. Plug flow was consdered wth axal dsperson and varyng velocty along the bed. Extended Langmur model was chosen for the equlbrum adsorpton of each component n the gas mxture and ther parameters were predcted by sngle gas adsorpton experments. The breakthrough curves of the gases where determned at adsorpton and desorpton modes. The senstvty analyss of the model was carred out to ndcate the effect of feed pressure and flow rate on purty, and breakthrough curves of hydrogen. Keywords: adsorpton; Hydrogen purfcaton; double layered; dynamc modelng. 1. Introducton Hydrogen purfcaton usng layered bed pressure swng adsorpton (PSA) unts s one of the most common ndustral processes to produce Hydrogen wth purty for fuel and other ndustral applcatons. (Grande et al., 2007, Papadas et al., 2009 and Lopes et al., 2010). For the proper desgn and smulaton of the PSA unts, the adsorbent characterstcs and the effectve physcal parameters should be frstly dentfed. The equlbrum adsorpton model and ts parameters are the key components n characterzaton of the adsorbents propertes and they control the mass transfer zone and breakthrough curves n dynamc mode of adsorpton column. Therefore, dentfcaton of these parameters s the target of the present work. The sotherm and physcal parameters derved from the present work would be used n a further research for smulaton of the PSA process of hydrogen purfcaton. In the present work, frstly the expermental sotherms of H 2, N 2, CO, CO 2 and CH 4 are obtaned for the two adsorbents; actvated carbon and zeolte 5A at two temperatures. Thereafter, they are best ftted on Langmur equaton. The Langmur equaton and ts parameters are used n the dynamc model of a two- layered packed bed
2 column, and the senstvty analyss of the breakthrough curves and mass transfer zone s nvestgated wth operatonal condtons for the gaseous mxture. 2. Equlbrum adsorpton experments Frstly, the Zeolte5A adsorbents were condtoned for a perod of 3 hours by a 100 ml/mn flow of Helum at 573 K for pre-treatment. Before each test, both adsorbents loaded n adsorpton cell, were mantaned n vacuum (-0.8 barg) at 353 K for a perod of 3 hours to completely desorb all the adsorbed gases. In ths work, the measurements of pure gas equlbrum sotherms were conducted usng a statc volumetrc setup (Gholamhosseny M., et al., 2008 ). The experments were started wth a known ntal pressure and t was recorded to approach to a constant equlbrum condton. These tests were performed for all gases (H 2, CO, CO 2 and CH 4 ) on both actvated carbon and zeolte 5A n K and K at dfferent pressures up to 21 barg. The sotherm data were best ftted on Langmur model and the parameters of ths model were determned by fttng the model on the expermental results. 3. Dynamc adsorpton modelng The mass balance for each component of the mxture and the total mass balance n the element of fgure 1 were wrtten as follows: Fgure 1: Schematc dagram of adsorpton cell used for modelng Component mass balance: 2 N Y Y Y Y P RT (1 εb ) q q = Dz u + ρ 2 P Y ρp t z z P t P ε (1) b t = 1 t Total mass balance: N C ( uc ) (1 ε ) ρ q = t t t t b P z ε b = 1 Mass transfer rates are expressed as lnear drvng force (LDF) model. q * = k( q q ) (3) t The mult-component adsorpton equlbrum model s represented by the extended Langmur sotherm, In whch the constants b and q s depend on the temperature as equaton (5),(6) followng way: (2)
3 q * sbpy q = (4) () n 1 + bpy j = 1 b =b exp (b / R T ) 0 1 (5) q s =a +a /,1,2 T (6) Ergun s equaton was appled to the pressure drop along the bed. 2 2 dp 150 µ (1 - ε ) V 1.75 ρ(1 - ε ) V = + (7) dz ( φ d p ) ε φ d pε Boundary condton: PY P u RT z = 0: = RT [ Y Y f ], u = u F, P = P z D z F (8) z PY RT = L : = 0 z (9) Intal condton: Y H2 (z, 0) =1, Y (z, 0) =0, P (z, 0) =P f (10) To solve the above system of partal dfferental equatons, the spatal dervatves are dvded usng a backward dfference scheme, and the resultng ordnary dfferental equatons are solved wth the Runge-Kutta method n Matlab programmng software. 4. Result and Dscusson 4.1 Equlbrum models Sngle gas equlbrum sotherm tests were performed for the gases (H 2, CO, N 2, CO 2 and CH 4 ) on actvated carbon and zeolte 5A adsorbents n 298K and 308K. The results are shown graphcally n fgure 1. The result of equlbrum adsorpton experments was well ftted usng Langmur sotherm models. The parameters of ths model are derved and shown n table 1. As shown n fgure 1 equlbrum adsorpton of Hydrogen on both adsorbents obeys Henry's rule, therefore sotherm data of Hydrogen were ftted on Henry's model (eq. 11). The parameters for ths model are shown n table Dynamc adsorpton model The model was solved numercally for the adsorpton bed consstng of a 5.38 meter Actvated Carbon layer at the bottom of the bed and a 1.87 meter Zeolte 5A layer at the top loaded n a column of meter dameter. Feed to the column conssts of a
4 H 2 :CO 2 : CO: N2:CH4 wth molar composton of 0.757:0.18:0.007:0.024:0.032 and flow rate of 0.6 m 3 /s and pressure equal to 21 barg. Fgure 2(a) llustrates the breakthrough curve of the layered bed. The breakthrough curve s shown n fgure 2(b). At tme of 180 seconds the purty of Hydrogen approaches to In mass transfer zone of CO 2, the stronger adsorpton of CO 2 causes desorpton of other mpurtes as shown n the form of rollups n the breakthrough curves of other gases. Table1: The calculated parameters of Langmur model AC Zeolte a 1, a 2, b 0, b 1, CO E CO E N E CH E CO E CO E N E CH E Fgure 1: Result of sothermal equlbrum adsorpton experments ((a) Actvated Carbon, 308 K (b) Zeolte 5A, 308 K (c) Actvated Carbon, 298 K (d) Zeolte 5A, 298 K) Fgure 3(a) presents the concentraton profle of CO 2 along the bed length n varous tmes. The mass transfer zone moves along the bed length n the same drecton wth the
5 gas moton and gets to the end of the bed. In fgure 3(b) the model results of Hydrogen mole fracton s llustrated at varous tmes durng the desorpton step by the purge flow of pure hydrogen equal to the feed flow rate n adsorpton step. The amount of hydrogen n column s ncreased by ncreasng the tme because of more desorpton of mpurtes. * Table2: Parameters of Henry's model for adsorpton of Hydrogen ( q = IP P) Adsorbent Actvated Carbon Zeolte IP 1 (mol.bar -1.gr -1 ) Fgure 2: Breakthrough curve of all components (a) at the end of the column, (b) at the end of the AC layer Fgure 3: Mass transfer zone of CO 2 a) at adsorpton mode, b) at desorpton mode Fgure 4(a) llustrates the breakthrough curve of Hydrogen at dfferent feed pressures. Wth ncreasng the feed pressure, the bed s saturated faster resultng n lower breakthrough tme. Fgure 4(b) demonstrates the breakthrough curve of Hydrogen at dfferent feed flow rates. Wth ncreasng the feed flow rate, the rate of adsorpton ncreases resultng n a shorter breakthrough tme.
6 Curves n a layered bed of Actvated Carbon and 5A Zeolte s studed n the ndustral scale column. The adsorpton sotherm models and ther parameters were determned by 5. Conclusons In the present work, dynamc adsorpton of methane steam reformng products; mxture of H 2, CO 2, CO, N 2 and CH 4, s studed by mathematcal modelng of breakthrough the statc experments carred out for each type of adsorbent; AC and 5A zeolte and they were well ftted on the Extended Langmur equaton for the mxture adsorpton. Fgure 4: Effect of feed pressure (a) and feed flow rate (b) on breakthrough of Hydrogen The dynamc adsorpton-desorpton model was developed for the gas speces wth pressure drop and varaton of the gas velocty along the bed. Breakthrough curves for both adsorpton and desorpton modes were determned and reported. It was concluded that after a perod of 180 seconds workng at adsorpton mode, the purty of Hydrogen would be 99.9%. References Gholamhosseny M., Fatem S. and Rasoolzadeh M., 2008, Hydrogen adsorpton and equlbrum models on multwalled carbon nanotubes at moderate temperatures and pressures, Internatonal Journal of Chemcal Reactor Engneerng 6, art. No. A80. Grande C.A., Lopes F, Rbero A., Lourero J., and Rodrgues A., 2008, Adsorpton of Off-Gases from Steam Methane Reformng (H2, CO2, CH4, CO and N2) on Actvated Carbon, Separaton Scence and Technology, 43: Lopes, F.V.S., Grande C.A., Rodrgues A.E., 2010, Actvated carbon for hydrogen purfcaton by pressure swng adsorpton: Multcomponent breakthrough curves and PSA performance. Chemcal Engneerng Scence, do: /j.ces Papadas D., Ahmed SH., Kumar R. and Joseck F., 2009, Hydrogen Qualty for Fuel Cell Vehcles A Modelng Study of The Senstvty of Impurty Content n Hydrogen to The Process Varables n The SMR PSA Pathway, nternatonal journal of hydrogen energy 34,
A New Steps Sequence Table to Improve the Performance of the Jam Petrochemical H 2 -PSA Industrial Plant
The 14 th Natnal Chemcal Engneerng Congress (IChEC 01) Sharf Unversty of Technology, Tehran, Iran, 16-18 October, 01 A New Steps Sequence Table to Improve the Performance of the Jam Petrochemcal H -PSA
More informationESA modelling and cycle design
ESA modellng and cycle desgn WP and WP 5 Unversty of Belgrade MATESA Dssemnaton day, Oslo 16.6.016 Motvaton Develop rgorous 3D models (CFD) to understand the processes, examne the nfluence of condtons
More informationCOMPARISON OF SOME RELIABILITY CHARACTERISTICS BETWEEN REDUNDANT SYSTEMS REQUIRING SUPPORTING UNITS FOR THEIR OPERATIONS
Avalable onlne at http://sck.org J. Math. Comput. Sc. 3 (3), No., 6-3 ISSN: 97-537 COMPARISON OF SOME RELIABILITY CHARACTERISTICS BETWEEN REDUNDANT SYSTEMS REQUIRING SUPPORTING UNITS FOR THEIR OPERATIONS
More informationCHEMICAL ENGINEERING
Postal Correspondence GATE & PSUs -MT To Buy Postal Correspondence Packages call at 0-9990657855 1 TABLE OF CONTENT S. No. Ttle Page no. 1. Introducton 3 2. Dffuson 10 3. Dryng and Humdfcaton 24 4. Absorpton
More informationMass Transfer Processes
Mass Transfer Processes S. Majd Hassanzadeh Department of Earth Scences Faculty of Geoscences Utrecht Unversty Outlne: 1. Measures of Concentraton 2. Volatlzaton and Dssoluton 3. Adsorpton Processes 4.
More informationJournal of Separation Science and Engineering Vol. 1, No. 1, 2009, pp MATLAB
Journal of Separaton Scence and Engneerng Vol. 1, No. 1, 29, pp. 1-11.. /.. 5 (... MT.. : : 5 ( ;...... [ ]. MT.. -٢ PS. PS........ ( (. /. -١ ( Pressure Swng dsorpton, PS...[ ]. Skarstrom..[ ] PS... :....[
More informationAssignment 4. Adsorption Isotherms
Insttute of Process Engneerng Assgnment 4. Adsorpton Isotherms Part A: Compettve adsorpton of methane and ethane In large scale adsorpton processes, more than one compound from a mxture of gases get adsorbed,
More informationModeling of CO 2. Adsorption on Activated Carbon and 13X Zeolite via Vacuum Swing Adsorption. IOP Conference Series: Materials Science and Engineering
IOP Conference Seres: Materals Scence and Engneerng PAPER OPEN ACCESS Modelng of CO Adsorpton on and 3X Zeolte va Vacuum Swng Adsorpton To cte ths artcle: M H Zarghampoor et al 7 IOP Conf. Ser.: Mater.
More informationInfluence Of Operating Conditions To The Effectiveness Of Extractive Distillation Columns
Influence Of Operatng Condtons To The Effectveness Of Extractve Dstllaton Columns N.A. Vyazmna Moscov State Unversty Of Envrnmental Engneerng, Department Of Chemcal Engneerng Ul. Staraya Basmannaya 21/4,
More informationOpen Systems: Chemical Potential and Partial Molar Quantities Chemical Potential
Open Systems: Chemcal Potental and Partal Molar Quanttes Chemcal Potental For closed systems, we have derved the followng relatonshps: du = TdS pdv dh = TdS + Vdp da = SdT pdv dg = VdP SdT For open systems,
More informationBasic concept of reactive flows. Basic concept of reactive flows Combustion Mixing and reaction in high viscous fluid Application of Chaos
Introducton to Toshhsa Ueda School of Scence for Open and Envronmental Systems Keo Unversty, Japan Combuston Mxng and reacton n hgh vscous flud Applcaton of Chaos Keo Unversty 1 Keo Unversty 2 What s reactve
More informationMathematical Modeling of an Industrial Naphtha Reformer with Three Adiabatic Reactors in Series
Iran. J. Chem. Chem. Eng. Research Note Vol. 28, No. 3, 2009 Mathematcal Modelng of an Industral Naphtha Reformer wth Three Adabatc Reactors n Seres Fazel, Al; Fatem, Shohreh* + ; Mahdavan, Mohammad; Ghaee,
More informationTHE EFFECT OF TORSIONAL RIGIDITY BETWEEN ELEMENTS ON FREE VIBRATIONS OF A TELESCOPIC HYDRAULIC CYLINDER SUBJECTED TO EULER S LOAD
Journal of Appled Mathematcs and Computatonal Mechancs 7, 6(3), 7- www.amcm.pcz.pl p-issn 99-9965 DOI:.75/jamcm.7.3. e-issn 353-588 THE EFFECT OF TORSIONAL RIGIDITY BETWEEN ELEMENTS ON FREE VIBRATIONS
More informationAmplification and Relaxation of Electron Spin Polarization in Semiconductor Devices
Amplfcaton and Relaxaton of Electron Spn Polarzaton n Semconductor Devces Yury V. Pershn and Vladmr Prvman Center for Quantum Devce Technology, Clarkson Unversty, Potsdam, New York 13699-570, USA Spn Relaxaton
More informationSTUDY ON TWO PHASE FLOW IN MICRO CHANNEL BASED ON EXPERI- MENTS AND NUMERICAL EXAMINATIONS
Blucher Mechancal Engneerng Proceedngs May 0, vol., num. www.proceedngs.blucher.com.br/evento/0wccm STUDY ON TWO PHASE FLOW IN MICRO CHANNEL BASED ON EXPERI- MENTS AND NUMERICAL EXAMINATIONS Takahko Kurahash,
More informationCOMPOSITE BEAM WITH WEAK SHEAR CONNECTION SUBJECTED TO THERMAL LOAD
COMPOSITE BEAM WITH WEAK SHEAR CONNECTION SUBJECTED TO THERMAL LOAD Ákos Jósef Lengyel, István Ecsed Assstant Lecturer, Professor of Mechancs, Insttute of Appled Mechancs, Unversty of Mskolc, Mskolc-Egyetemváros,
More information(Online First)A Lattice Boltzmann Scheme for Diffusion Equation in Spherical Coordinate
Internatonal Journal of Mathematcs and Systems Scence (018) Volume 1 do:10.494/jmss.v1.815 (Onlne Frst)A Lattce Boltzmann Scheme for Dffuson Equaton n Sphercal Coordnate Debabrata Datta 1 *, T K Pal 1
More informationProcess Modeling. Improving or understanding chemical process operation is a major objective for developing a dynamic process model
Process Modelng Improvng or understandng chemcal process operaton s a major objectve for developng a dynamc process model Balance equatons Steady-state balance equatons mass or energy mass or energy enterng
More informationA Modulated Hydrothermal (MHT) Approach for the Facile. Synthesis of UiO-66-Type MOFs
Supplementary Informaton A Modulated Hydrothermal (MHT) Approach for the Facle Synthess of UO-66-Type MOFs Zhgang Hu, Yongwu Peng, Zx Kang, Yuhong Qan, and Dan Zhao * Department of Chemcal and Bomolecular
More informationRelationship between Refractive Index and Molar Concentration of Multi-Component Solutions Zhu Xingyu 1, a, Mai Tiancheng 2, b and Zhao Zilong 2, c
Advances n Computer Scence Research, volume 71 4th Internatonal Conference on Machnery, Materals and Informaton Technology Applcatons (ICMMITA 2016) Relatonshp between Refractve Index and Molar Concentraton
More informationApplication of Finite Element Method (FEM) Instruction to Graduate Courses in Biological and Agricultural Engineering
Sesson: 08 Applcaton of Fnte Element Method (FEM) Instructon to Graduate Courses n Bologcal and Agrcultural Engneerng Chang S. Km, Terry H. Walker, Caye M. Drapcho Dept. of Bologcal and Agrcultural Engneerng
More informationINFLUENCE OF AXIAL MIXING AND PARTICLE SIZE NON-UNIFORMITY ON PERFORMANCE OF CHROMATOGRAPHIC REACTORS
14 th European onference on Mxng Warszawa, 1-13 September 1 INFUENE OF XI MIXING N PRTIE SIZE NON-UNIFORMITY ON PERFORMNE OF HROMTOGRPHI RETORS Eugenusz Molga, Mchał ewak, nna Ostanewcz-ydzk Warsaw Unversty
More informationIntroduction to Vapor/Liquid Equilibrium, part 2. Raoult s Law:
CE304, Sprng 2004 Lecture 4 Introducton to Vapor/Lqud Equlbrum, part 2 Raoult s Law: The smplest model that allows us do VLE calculatons s obtaned when we assume that the vapor phase s an deal gas, and
More informationADSORPTION EQUILIBRIUM OF LIGHT HYDROCARBON MIXTURES BY MONTE CARLO SIMULATION
Brazlan Journal of Chemcal Engneerng ISSN 0104-6632 Prnted n Brazl www.abeq.org.br/bjche Vol. 24, No. 04, pp. 597-610 October - December, 2007 ADSORPTION EQUILIBRIUM OF LIGHT HYDROCARBON MIXTURES BY MONTE
More information( ) 1/ 2. ( P SO2 )( P O2 ) 1/ 2.
Chemstry 360 Dr. Jean M. Standard Problem Set 9 Solutons. The followng chemcal reacton converts sulfur doxde to sulfur troxde. SO ( g) + O ( g) SO 3 ( l). (a.) Wrte the expresson for K eq for ths reacton.
More information10.34 Numerical Methods Applied to Chemical Engineering Fall Homework #3: Systems of Nonlinear Equations and Optimization
10.34 Numercal Methods Appled to Chemcal Engneerng Fall 2015 Homework #3: Systems of Nonlnear Equatons and Optmzaton Problem 1 (30 ponts). A (homogeneous) azeotrope s a composton of a multcomponent mxture
More informationSolution Thermodynamics
Soluton hermodynamcs usng Wagner Notaton by Stanley. Howard Department of aterals and etallurgcal Engneerng South Dakota School of nes and echnology Rapd Cty, SD 57701 January 7, 001 Soluton hermodynamcs
More informationAdsorption of Chlorinated Volatile Organic Compounds in a Fixed Bed of Activated Carbon
Korean J. Chem. Eng., 9(), 6-67 (2002) Adsorpton of Chlornated Volatle Organc Compounds n a Fxed Bed of Actvated Carbon Seung Ja Km, Sung Yong Cho and Tae Young Km Department of Envronmental Engneerng,
More informationNON-CENTRAL 7-POINT FORMULA IN THE METHOD OF LINES FOR PARABOLIC AND BURGERS' EQUATIONS
IJRRAS 8 (3 September 011 www.arpapress.com/volumes/vol8issue3/ijrras_8_3_08.pdf NON-CENTRAL 7-POINT FORMULA IN THE METHOD OF LINES FOR PARABOLIC AND BURGERS' EQUATIONS H.O. Bakodah Dept. of Mathematc
More informationEthyl Lactate Synthesis using A15 resin as Catalyst/Adsorbent: Kinetic and Adsorption Studies
Ethyl Lactate Synthess usng A15 resn as Catalyst/Adsorbent: Knetc and Adsorpton Studes Carla S.M. Perera 1, Smão P. Pnho, Vvana M.T.M. Slva 1, and Alíro E. Rodrgues 1 1 Laboratory of Separaton and Reacton
More informationLecture. Polymer Thermodynamics 0331 L Chemical Potential
Prof. Dr. rer. nat. habl. S. Enders Faculty III for Process Scence Insttute of Chemcal Engneerng Department of Thermodynamcs Lecture Polymer Thermodynamcs 033 L 337 3. Chemcal Potental Polymer Thermodynamcs
More informationNote 10. Modeling and Simulation of Dynamic Systems
Lecture Notes of ME 475: Introducton to Mechatroncs Note 0 Modelng and Smulaton of Dynamc Systems Department of Mechancal Engneerng, Unversty Of Saskatchewan, 57 Campus Drve, Saskatoon, SK S7N 5A9, Canada
More informationTransfer Functions. Convenient representation of a linear, dynamic model. A transfer function (TF) relates one input and one output: ( ) system
Transfer Functons Convenent representaton of a lnear, dynamc model. A transfer functon (TF) relates one nput and one output: x t X s y t system Y s The followng termnology s used: x y nput output forcng
More informationEVALUATION OF THE VISCO-ELASTIC PROPERTIES IN ASPHALT RUBBER AND CONVENTIONAL MIXES
EVALUATION OF THE VISCO-ELASTIC PROPERTIES IN ASPHALT RUBBER AND CONVENTIONAL MIXES Manuel J. C. Mnhoto Polytechnc Insttute of Bragança, Bragança, Portugal E-mal: mnhoto@pb.pt Paulo A. A. Perera and Jorge
More informationCHAPTER 5 NUMERICAL EVALUATION OF DYNAMIC RESPONSE
CHAPTER 5 NUMERICAL EVALUATION OF DYNAMIC RESPONSE Analytcal soluton s usually not possble when exctaton vares arbtrarly wth tme or f the system s nonlnear. Such problems can be solved by numercal tmesteppng
More informationElectrical double layer: revisit based on boundary conditions
Electrcal double layer: revst based on boundary condtons Jong U. Km Department of Electrcal and Computer Engneerng, Texas A&M Unversty College Staton, TX 77843-318, USA Abstract The electrcal double layer
More informationModeling of CO 2 Cut in CBM Production
Modelng of CO Cut n CBM Producton A study by: - Kamal Morad - Davd Dunn - ous Mattar Fekete Assocates Inc. Mult-Component Gas n Coalbed Methane Coalbed Methane has dfferent characterstcs from conventonal
More informationDesign Equations. ν ij r i V R. ν ij r i. Q n components. = Q f c jf Qc j + Continuous Stirred Tank Reactor (steady-state and constant phase)
Desgn Equatons Batch Reactor d(v R c j ) dt = ν j r V R n dt dt = UA(T a T) r H R V R ncomponents V R c j C pj j Plug Flow Reactor d(qc j ) dv = ν j r 2 dt dv = R U(T a T) n r H R Q n components j c j
More informationDETERMINATION OF TEMPERATURE DISTRIBUTION FOR ANNULAR FINS WITH TEMPERATURE DEPENDENT THERMAL CONDUCTIVITY BY HPM
Ganj, Z. Z., et al.: Determnaton of Temperature Dstrbuton for S111 DETERMINATION OF TEMPERATURE DISTRIBUTION FOR ANNULAR FINS WITH TEMPERATURE DEPENDENT THERMAL CONDUCTIVITY BY HPM by Davood Domr GANJI
More informationINTRODUCTION TO CHEMICAL PROCESS SIMULATORS
INTRODUCTION TO CHEMICAL PROCESS SIMULATORS DWSIM Chemcal Process Smulator A. Carrero, N. Qurante, J. Javaloyes October 2016 Introducton to Chemcal Process Smulators Contents Monday, October 3 rd 2016
More informationLattice Boltzmann simulation of nucleate boiling in micro-pillar structured surface
Proceedngs of the Asan Conference on Thermal Scences 017, 1st ACTS March 6-30, 017, Jeju Island, Korea ACTS-P00545 Lattce Boltzmann smulaton of nucleate bolng n mcro-pllar structured surface Png Zhou,
More information829. An adaptive method for inertia force identification in cantilever under moving mass
89. An adaptve method for nerta force dentfcaton n cantlever under movng mass Qang Chen 1, Mnzhuo Wang, Hao Yan 3, Haonan Ye 4, Guola Yang 5 1,, 3, 4 Department of Control and System Engneerng, Nanng Unversty,
More informationAn identification algorithm of model kinetic parameters of the interfacial layer growth in fiber composites
IOP Conference Seres: Materals Scence and Engneerng PAPER OPE ACCESS An dentfcaton algorthm of model knetc parameters of the nterfacal layer growth n fber compostes o cte ths artcle: V Zubov et al 216
More informationFORCED CONVECTION HEAT TRANSFER FROM A RECTANGULAR CYLINDER: EFFECT OF ASPECT RATIO
ISTP-,, PRAGUE TH INTERNATIONAL SYMPOSIUM ON TRANSPORT PHENOMENA FORCED CONVECTION HEAT TRANSFER FROM A RECTANGULAR CYLINDER: EFFECT OF ASPECT RATIO Mohammad Rahnama*, Seyed-Mad Hasheman*, Mousa Farhad**
More informationLNG CARGO TRANSFER CALCULATION METHODS AND ROUNDING-OFFS
CARGO TRANSFER CALCULATION METHODS AND ROUNDING-OFFS CONTENTS 1. Method for determnng transferred energy durng cargo transfer. Calculatng the transferred energy.1 Calculatng the gross transferred energy.1.1
More informationIrregular vibrations in multi-mass discrete-continuous systems torsionally deformed
(2) 4 48 Irregular vbratons n mult-mass dscrete-contnuous systems torsonally deformed Abstract In the paper rregular vbratons of dscrete-contnuous systems consstng of an arbtrary number rgd bodes connected
More informationEquation of State Modeling of Phase Equilibrium in the Low-Density Polyethylene Process
Equaton of State Modelng of Phase Equlbrum n the Low-Densty Polyethylene Process H. Orbey, C. P. Boks, and C. C. Chen Ind. Eng. Chem. Res. 1998, 37, 4481-4491 Yong Soo Km Thermodynamcs & Propertes Lab.
More informationThermodynamics II. Department of Chemical Engineering. Prof. Kim, Jong Hak
Thermodynamcs II Department of Chemcal Engneerng Prof. Km, Jong Hak Soluton Thermodynamcs : theory Obectve : lay the theoretcal foundaton for applcatons of thermodynamcs to gas mxture and lqud soluton
More informationA NUMERICAL COMPARISON OF LANGRANGE AND KANE S METHODS OF AN ARM SEGMENT
Internatonal Conference Mathematcal and Computatonal ology 0 Internatonal Journal of Modern Physcs: Conference Seres Vol. 9 0 68 75 World Scentfc Publshng Company DOI: 0.4/S009450059 A NUMERICAL COMPARISON
More informationConstitutive Modelling of Superplastic AA-5083
TECHNISCHE MECHANIK, 3, -5, (01, 1-6 submtted: September 19, 011 Consttutve Modellng of Superplastc AA-5083 G. Gulano In ths study a fast procedure for determnng the constants of superplastc 5083 Al alloy
More informationThree-Phase Distillation in Packed Towers: Short-Cut Modelling and Parameter Tuning
European Symposum on Computer Arded Aded Process Engneerng 15 L. Pugjaner and A. Espuña (Edtors) 2005 Elsever Scence B.V. All rghts reserved. Three-Phase Dstllaton n Packed Towers: Short-Cut Modellng and
More informationMathematical modeling for finding the thermal conductivity of solid materials
Mathematcal modelng for fndng the thermal conductvty of sold materals Farhan Babu 1, Akhlesh Lodwal 1 PG Scholar, Assstant Professor Mechancal Engneerng Department Dev AhlyaVshwavdyalaya, Indore, Inda
More informationCOW MILK WHEY THROUGH EXPANDED BED ADSORPTION USING A HYDROPHOBIC RESIN
Brazlan Journal of Chemcal Engneerng ISSN 004-663 Prnted n Brazl www.abeq.org.br/bjche Vol., No. 04, pp. 50-509, October - December, 005 CONCENTRATION OF α-lactalbumin FROM COW MILK WHEY THROUGH EXPANDED
More informationWinter 2008 CS567 Stochastic Linear/Integer Programming Guest Lecturer: Xu, Huan
Wnter 2008 CS567 Stochastc Lnear/Integer Programmng Guest Lecturer: Xu, Huan Class 2: More Modelng Examples 1 Capacty Expanson Capacty expanson models optmal choces of the tmng and levels of nvestments
More informationAerosols, Dust and High Spectral Resolution Remote Sensing
Aerosols, Dust and Hgh Spectral Resoluton Remote Sensng Irna N. Sokolk Program n Atmospherc and Oceanc Scences (PAOS) Unversty of Colorado at Boulder rna.sokolk@colorado.edu Goals and challenges MAIN GOALS:
More informationA Hybrid Variational Iteration Method for Blasius Equation
Avalable at http://pvamu.edu/aam Appl. Appl. Math. ISSN: 1932-9466 Vol. 10, Issue 1 (June 2015), pp. 223-229 Applcatons and Appled Mathematcs: An Internatonal Journal (AAM) A Hybrd Varatonal Iteraton Method
More informationThe First Example of Commensurate Adsorption of Atomic Gas in a MOF and Effective Separation of Xenon from Other Noble Gases
The Frst Example of Commensurate Adsorpton of Atomc Gas n a MOF and Effectve Separaton of Xenon from Other Noble Gases Hao Wang, a Ke Xn Yao, b Zhjuan Zhang, c Jacek Jagello, d Qhan Gong, a Yu Han b and
More information2010 Black Engineering Building, Department of Mechanical Engineering. Iowa State University, Ames, IA, 50011
Interface Energy Couplng between -tungsten Nanoflm and Few-layered Graphene Meng Han a, Pengyu Yuan a, Jng Lu a, Shuyao S b, Xaolong Zhao b, Yanan Yue c, Xnwe Wang a,*, Xangheng Xao b,* a 2010 Black Engneerng
More informationa for save as PDF Chemistry 163B Introduction to Multicomponent Systems and Partial Molar Quantities
a for save as PDF Chemstry 163B Introducton to Multcomponent Systems and Partal Molar Quanttes 1 the problem of partal mmolar quanttes mx: 10 moles ethanol C 2 H 5 OH (580 ml) wth 1 mole water H 2 O (18
More informationStatistical Energy Analysis for High Frequency Acoustic Analysis with LS-DYNA
14 th Internatonal Users Conference Sesson: ALE-FSI Statstcal Energy Analyss for Hgh Frequency Acoustc Analyss wth Zhe Cu 1, Yun Huang 1, Mhamed Soul 2, Tayeb Zeguar 3 1 Lvermore Software Technology Corporaton
More informationA novel mathematical model of formulation design of emulsion explosive
J. Iran. Chem. Res. 1 (008) 33-40 Journal of the Iranan Chemcal Research IAU-ARAK www.au-jcr.com A novel mathematcal model of formulaton desgn of emulson explosve Mng Lu *, Qfa Lu Chemcal Engneerng College,
More informationPETE 310 Lectures # 24 & 25 Chapter 12 Gas Liquid Equilibrium
ETE 30 Lectures # 24 & 25 Chapter 2 Gas Lqud Equlbrum Thermal Equlbrum Object A hgh T, Object B low T Intal contact tme Intermedate tme. Later tme Mechancal Equlbrum ressure essels Vale Closed Vale Open
More informationA study on the effect of ball diameter on breakage properties of clinker and limestone
Indan Journal of Chemcal Technology Vol. 9, May 202, pp. 80-84 A study on the effect of ball dameter on breakage propertes of clnker and lmestone Vedat Denz* Department of Chemcal Engneerng, Htt Unversty,
More information2.If the concentration is of bulk phenomenon, it is absorption. (e.g) Absorption of Ink on the surface of a chalk.
183101 EGIEERIG CHEMISTRY UIT 3 SURFACE CHEMISTRY TERMS AD DEFIITIOS: 1. Adsorpton: Concentraton of lqud or gaseous molecules over the surface of a sold materal s known as adsorpton. It s a surface phenomenon.
More informationDESIGN OPTIMIZATION OF CFRP RECTANGULAR BOX SUBJECTED TO ARBITRARY LOADINGS
Munch, Germany, 26-30 th June 2016 1 DESIGN OPTIMIZATION OF CFRP RECTANGULAR BOX SUBJECTED TO ARBITRARY LOADINGS Q.T. Guo 1*, Z.Y. L 1, T. Ohor 1 and J. Takahash 1 1 Department of Systems Innovaton, School
More informationWeek3, Chapter 4. Position and Displacement. Motion in Two Dimensions. Instantaneous Velocity. Average Velocity
Week3, Chapter 4 Moton n Two Dmensons Lecture Quz A partcle confned to moton along the x axs moves wth constant acceleraton from x =.0 m to x = 8.0 m durng a 1-s tme nterval. The velocty of the partcle
More informationAdiabatic Sorption of Ammonia-Water System and Depicting in p-t-x Diagram
Adabatc Sorpton of Ammona-Water System and Depctng n p-t-x Dagram J. POSPISIL, Z. SKALA Faculty of Mechancal Engneerng Brno Unversty of Technology Techncka 2, Brno 61669 CZECH REPUBLIC Abstract: - Absorpton
More informationGasometric Determination of NaHCO 3 in a Mixture
60 50 40 0 0 5 15 25 35 40 Temperature ( o C) 9/28/16 Gasometrc Determnaton of NaHCO 3 n a Mxture apor Pressure (mm Hg) apor Pressure of Water 1 NaHCO 3 (s) + H + (aq) Na + (aq) + H 2 O (l) + CO 2 (g)
More informationThe Exact Formulation of the Inverse of the Tridiagonal Matrix for Solving the 1D Poisson Equation with the Finite Difference Method
Journal of Electromagnetc Analyss and Applcatons, 04, 6, 0-08 Publshed Onlne September 04 n ScRes. http://www.scrp.org/journal/jemaa http://dx.do.org/0.46/jemaa.04.6000 The Exact Formulaton of the Inverse
More informationCFD Simulation of Dense Gas Extraction through Polymeric Membranes
Vol:4, No:1, 010 CF Smulaton of ense Gas Extracton through Polymerc Membranes Azam Marjan*, Saeed Shrazan Internatonal Scence Index, Chemcal and Molecular Engneerng Vol:4, No:1, 010 waset.org/publcaton/430
More informationCalculating the Quasi-static Pressures of Confined Explosions Considering Chemical Reactions under the Constant Entropy Assumption
Appled Mechancs and Materals Onlne: 202-04-20 ISS: 662-7482, ol. 64, pp 396-400 do:0.4028/www.scentfc.net/amm.64.396 202 Trans Tech Publcatons, Swtzerland Calculatng the Quas-statc Pressures of Confned
More informationStudy on Active Micro-vibration Isolation System with Linear Motor Actuator. Gong-yu PAN, Wen-yan GU and Dong LI
2017 2nd Internatonal Conference on Electrcal and Electroncs: echnques and Applcatons (EEA 2017) ISBN: 978-1-60595-416-5 Study on Actve Mcro-vbraton Isolaton System wth Lnear Motor Actuator Gong-yu PAN,
More information1. Mathematical models of the chromatographic process
1. athematcal models of the chromatographc process - What determnes retenton tme n L? - What causes pea broadenng n L? - Why are the L peas often asymmetrc? - Why s partton chromatography much more popular
More informationSupplementary Notes for Chapter 9 Mixture Thermodynamics
Supplementary Notes for Chapter 9 Mxture Thermodynamcs Key ponts Nne major topcs of Chapter 9 are revewed below: 1. Notaton and operatonal equatons for mxtures 2. PVTN EOSs for mxtures 3. General effects
More informationABSTRACT
RELIABILITY AND SENSITIVITY ANALYSIS OF THE K-OUT-OF-N:G WARM STANDBY PARALLEL REPAIRABLE SYSTEM WITH REPLACEMENT AT COMMON-CAUSE FAILURE USING MARKOV MODEL M. A. El-Damcese 1 and N. H. El-Sodany 2 1 Mathematcs
More informationis the calculated value of the dependent variable at point i. The best parameters have values that minimize the squares of the errors
Multple Lnear and Polynomal Regresson wth Statstcal Analyss Gven a set of data of measured (or observed) values of a dependent varable: y versus n ndependent varables x 1, x, x n, multple lnear regresson
More informationApplication of B-Spline to Numerical Solution of a System of Singularly Perturbed Problems
Mathematca Aeterna, Vol. 1, 011, no. 06, 405 415 Applcaton of B-Splne to Numercal Soluton of a System of Sngularly Perturbed Problems Yogesh Gupta Department of Mathematcs Unted College of Engneerng &
More informationPrediction of steady state input multiplicities for the reactive flash separation using reactioninvariant composition variables
Insttuto Tecnologco de Aguascalentes From the SelectedWorks of Adran Bonlla-Petrcolet 2 Predcton of steady state nput multplctes for the reactve flash separaton usng reactonnvarant composton varables Jose
More informationMonte Carlo simulation study on magnetic hysteresis loop of Co nanowires
Monte Carlo smulaton study on magnetc hysteress loop of Co nanowres Ryang Se-Hun, O Pong-Sk, Sn Gum-Chol, Hwang Guk-Nam, Hong Yong-Son * Km Hyong Jk Normal Unversty, Pyongyang, D.P.R of Korea Abstract;
More informationThermal-Fluids I. Chapter 18 Transient heat conduction. Dr. Primal Fernando Ph: (850)
hermal-fluds I Chapter 18 ransent heat conducton Dr. Prmal Fernando prmal@eng.fsu.edu Ph: (850) 410-6323 1 ransent heat conducton In general, he temperature of a body vares wth tme as well as poston. In
More informationResearch Article Green s Theorem for Sign Data
Internatonal Scholarly Research Network ISRN Appled Mathematcs Volume 2012, Artcle ID 539359, 10 pages do:10.5402/2012/539359 Research Artcle Green s Theorem for Sgn Data Lous M. Houston The Unversty of
More information2 Finite difference basics
Numersche Methoden 1, WS 11/12 B.J.P. Kaus 2 Fnte dfference bascs Consder the one- The bascs of the fnte dfference method are best understood wth an example. dmensonal transent heat conducton equaton T
More informationName: SID: Discussion Session:
Name: SID: Dscusson Sesson: Chemcal Engneerng Thermodynamcs 141 -- Fall 007 Thursday, November 15, 007 Mdterm II SOLUTIONS - 70 mnutes 110 Ponts Total Closed Book and Notes (0 ponts) 1. Evaluate whether
More informationConsistency & Convergence
/9/007 CHE 374 Computatonal Methods n Engneerng Ordnary Dfferental Equatons Consstency, Convergence, Stablty, Stffness and Adaptve and Implct Methods ODE s n MATLAB, etc Consstency & Convergence Consstency
More informationEnergy, Entropy, and Availability Balances Phase Equilibria. Nonideal Thermodynamic Property Models. Selecting an Appropriate Model
Lecture 4. Thermodynamcs [Ch. 2] Energy, Entropy, and Avalablty Balances Phase Equlbra - Fugactes and actvty coeffcents -K-values Nondeal Thermodynamc Property Models - P-v-T equaton-of-state models -
More informationLecture 12. Transport in Membranes (2)
Lecture 12. Transport n embranes (2) odule Flow Patterns - Perfect mxng - Countercurrent flow - Cocurrent flow - Crossflow embrane Cascades External ass-transfer Resstances Concentraton Polarzaton and
More informationModule 3: The Whole-Process Perspective for Thermochemical Hydrogen
"Thermodynamc Analyss of Processes for Hydrogen Generaton by Decomposton of Water" by John P. O'Connell Department of Chemcal Engneerng Unversty of Vrgna Charlottesvlle, VA 2294-4741 A Set of Energy Educaton
More informationAir Age Equation Parameterized by Ventilation Grouped Time WU Wen-zhong
Appled Mechancs and Materals Submtted: 2014-05-07 ISSN: 1662-7482, Vols. 587-589, pp 449-452 Accepted: 2014-05-10 do:10.4028/www.scentfc.net/amm.587-589.449 Onlne: 2014-07-04 2014 Trans Tech Publcatons,
More informationModule 1 : The equation of continuity. Lecture 1: Equation of Continuity
1 Module 1 : The equaton of contnuty Lecture 1: Equaton of Contnuty 2 Advanced Heat and Mass Transfer: Modules 1. THE EQUATION OF CONTINUITY : Lectures 1-6 () () () (v) (v) Overall Mass Balance Momentum
More informationThermodynamics General
Thermodynamcs General Lecture 1 Lecture 1 s devoted to establshng buldng blocks for dscussng thermodynamcs. In addton, the equaton of state wll be establshed. I. Buldng blocks for thermodynamcs A. Dmensons,
More informationNumerical modelization by finite differences of a thermoelectric refrigeration device of double jump". Experimental validation.
Numercal modelzaton by fnte dfferences of a thermoelectrc refrgeraton devce of double jump". Expermental valdaton. A. Rodríguez, J.G. Ván, D. Astran, Dpto. Ingenería Mecánca, Energétca y de Materales.
More informationEN40: Dynamics and Vibrations. Homework 4: Work, Energy and Linear Momentum Due Friday March 1 st
EN40: Dynamcs and bratons Homework 4: Work, Energy and Lnear Momentum Due Frday March 1 st School of Engneerng Brown Unversty 1. The fgure (from ths publcaton) shows the energy per unt area requred to
More informationModeling of Dynamic Systems
Modelng of Dynamc Systems Ref: Control System Engneerng Norman Nse : Chapters & 3 Chapter objectves : Revew the Laplace transform Learn how to fnd a mathematcal model, called a transfer functon Learn how
More informationEffect of Water Gas Shift Reaction on the Non-Isothermal Reduction of Wustite Porous Pellet Using Syngas
Internatonal Journal of ISSI, Vol.8 (211, No.2, pp.9-15 Effect of Water Gas Shft Reacton on the Non-Isothermal Reducton of Wustte Porous Pellet Usng Syngas M. S. Valpour 1 * and M. H. Mokhtar 2 Heterogeneous
More informationCinChE Problem-Solving Strategy Chapter 4 Development of a Mathematical Model. formulation. procedure
nhe roblem-solvng Strategy hapter 4 Transformaton rocess onceptual Model formulaton procedure Mathematcal Model The mathematcal model s an abstracton that represents the engneerng phenomena occurrng n
More informationOPTIMISATION. Introduction Single Variable Unconstrained Optimisation Multivariable Unconstrained Optimisation Linear Programming
OPTIMIATION Introducton ngle Varable Unconstraned Optmsaton Multvarable Unconstraned Optmsaton Lnear Programmng Chapter Optmsaton /. Introducton In an engneerng analss, sometmes etremtes, ether mnmum or
More informationThe Tangential Force Distribution on Inner Cylinder of Power Law Fluid Flowing in Eccentric Annuli with the Inner Cylinder Reciprocating Axially
Open Journal of Flud Dynamcs, 2015, 5, 183-187 Publshed Onlne June 2015 n ScRes. http://www.scrp.org/journal/ojfd http://dx.do.org/10.4236/ojfd.2015.52020 The Tangental Force Dstrbuton on Inner Cylnder
More informationSelective Paraffin Removal from Olefin/Paraffin Mixtures by Adsorption to Aluminum Methylphosphate-α: A Molecular Simulation Study
Selectve Paraffn Removal from Olefn/Paraffn Mxtures by Adsorpton to Alumnum Methylphosphate-α: A Molecular Smulaton Study Maake C. Kroon 1,3, Carmelo Herdes and Lourdes F. Vega,3* 1 Process Equpment, Department
More informationSystem in Weibull Distribution
Internatonal Matheatcal Foru 4 9 no. 9 94-95 Relablty Equvalence Factors of a Seres-Parallel Syste n Webull Dstrbuton M. A. El-Dacese Matheatcs Departent Faculty of Scence Tanta Unversty Tanta Egypt eldacese@yahoo.co
More informationModeling of esterification-pervaporation integrated system with ethanol
Research Journal of Engneerng Scences ISSN 2278 9472 Vol. 6(3), -5, March (27) Modelng of esterfcaton-pervaporaton ntegrated system of acrylc acd wth ethanol Abstract Ghoshna Jyot *, Amt Keshav and J.
More information