PARTS GUIDE MANUAL JULY bizhub 200/250/350

Transcription

1 PARTS GUIDE MANUAL JULY 200 izhu 200/20/0

2 INFORMATION FOR PARTS GUIDE MANUAL To find orret Prts No., refer to the HOW TO MAKE THE BEST USE OF THIS MANUAL in the following pge. HOW TO MAKE THE BEST USE OF THIS MANUAL When you order, plese hek the proper figures eforehnd tht re on Our Prts Guide Mnul, nd order with the pproprite figures. 2 For srews, Nuts, Wshers, retining rings nd Pins whih re used in this model, one letter is shown on the Stndrd prts olumn of Prts list nd exploded digrms. In order to mintin sfety of the produt, some speifi prts omposed of this produt re set up s "essentil sfety prts". 4 The ssigned prts numer for the "essentil sfety prts" is indited s "SP00-****". When repling these prts, follow preutions for disssemling nd instlling whih re listed in the Servie Mnul. Do not use ny prts tht re not set up s mens tht there re exlusive prts for eh destintion. Plese hek the pproprite destintion when you order. 6 Revision Mrk Mrked s on the illustrtion shows tht the revision hs een mde. All rights reserved. (ny reprints or quottions re prohiited.) Use of this prts guide mnul should e stritly supervised to void dislosure of onfidentil informtion. 0/22/200

3 SYSTEM OUTLINE JAPAN ONLY EXCEPT JAPAN

4 GENERAL CONTENTS No. Desription Model DIGITAL MFP B/W 2 PAPER FEEDER PC-2 PAPER FEEDER PC PAPER FEEDER PC-402 SORTER/FINISHER FS-08 6 OTHER OPTION OT-60 SORTER/FINISHER MT-0 8 SORTER/FINISHER SD-02 9 PUNCH UNIT PU-0 DOCUMENT FEEDER DF-60 OTHER OPTION OC-02 2 STACKER JS-02 FAX CONTROLLER FK-0 4 FAX CONTROLLER HS-0

5 DIAGRAMS OF MAIN PARTS SECTION 4 REAR SIDE

6 CONTENTS No. DESCRIPTION PAGE No. IR COVER P 2 EXTERNAL PARTS P2 CONTROL PANEL P P4 4 OPTICALSECTION PP6PP8 POWER UNIT P9 6 FRAME SECTION P P PAPER TAKE-UP SECTION P2 P P4 P 8 BYPASS SECTION P6 P P8 9 HOPPER SECTION P9 P20 DEVELOPING UNIT P2 PAPER TRANSPORT SECTION P22 P2 2 DRIVE SECTION P24 P2 P26 FUSING SECTION P2 P28 4 ELECTRICAL COMPONENTS P29 P0 CASSETTE SECTION P 6 TURNOVER UNIT P2 DUPLEX UNIT P P4 8 WIRING P P6 P P8 P9 P40 P4 9 WIRING ACCESSORIES AND JIGS P42 20 ACCESSORY PARTS P4

7 INDEX / Prts No. Pge No Prts No. Pge No Prts No. Pge No Prts No. Pge No Prts No. Pge No

8 Prts No. Pge No Prts No. Pge No Prts No. Pge No Prts No. Pge No / Prts No. Pge No

9 Prts No. Pge No Prts No. Pge No Prts No. Pge No Prts No. Pge No / Prts No. Pge No

10 Prts No. Pge No Prts No. Pge No Prts No. Pge No Prts No. Pge No / Prts No. Pge No

11 Prts No. Pge No Prts No. Pge No Prts No. Pge No Prts No. Pge No / Prts No. Pge No

12 IR COVER P

13 IR COVER Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts RIGHT COVER C COVER C COVER C FRONT COVER C SEAL C LEFT COVER C COVER C REAR COVER C COVER C ORIGINAL GLASS ASSY C COVER C ORIGINAL GLASS ASSY C

14 EXTERNAL PARTS f 4 P 2 f 29 2 d 0 d g f 8 e e 2 e e e 2 e

15 EXTERNAL PARTS Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts TRAY C BRACKET D LABEL TONER POSITION C d STOPPER D e REGULATING PLATE C f COVER C g BRACKET D COVER C BAND C FRONT COVER C LABEL TONER REMOVE C LABEL LOGO MARK C STOPPER RING C CATCH D COVER C FRONT COVER C LABEL {izhu0} C LABEL {izhu20} C LABEL {izhu200} C COVER C FRONT COVER C COVER C TRAY D LEFT COVER C TRAY C CAP C COVER D REAR COVER D REAR COVER D REAR COVER D LEFT COVER C HANDLE D REAR COVER D TONER FILTER B REAR COVER C REAR COVER D RIGHT COVER C RIGHT COVER C LABEL EARTH CAUTION {izhu0/20} C,D,F2,G,I,K C

16 CONTROL PANEL P UN PWB-OK PWB-O PWB-O2 6 PWB-LCD PWB-OK2

17 CONTROL PANEL Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts CONTROL PANEL ASSY {izhu0/20} C I CONTROL PANEL ASSY A I CONTROL PANEL ASSY B,D,F,G,I,K I CONTROL PANEL ASSY {izhu0/20} J I CONTROL PANEL ASSY {izhu0/20} H I PWB-OK A D PWB-OK B,C,D,F,G,H,I,J,K D BUTTON KIT D TOUCH PANEL D LCD UNIT C PWB-O2 D PWB-OK2 D PWB-O A D PWB-O B,D,F,G,I,K D PWB-O {izhu0/20} C D PWB-O {izhu0/20} J D PWB-O {izhu0/20} H D

18 CONTROL PANEL d 2 d 4 6 e P 4 d 8 SP 6 e f g g

19 CONTROL PANEL Pge. 4 Key Prt No. Desription Destintions Clss QTY Stndrd prts PLATE SPRING D BRACKET D TENSION SPRING C d COUPLING D e POSITIONING PLATE D 2 f HOLD PLATE D g TORSION SPRING C LEVER C BRACKET D COVER C COVER C COVER C SEAL C COVER C COVER C LOUDSPEAKER D TORSION SPRING C HOLD PLATE D

20 OPTICAL SECTION P 2 MFBS MEMS BS HEATER KIT (OPTION)

21 OPTICAL SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts SHIELD D MFBS I SCREW C MEMS C BRACKET D LEVER C PLATE SPRING C HEATER ASSY A S

22 OPTICAL SECTION 2 PC20 PC20 PC202 PC P 6 BCRS 4 PC PC20 PC206 SW20

23 OPTICAL SECTION Pge. 6 Key Prt No. Desription Destintions Clss QTY Stndrd prts HOLDER C SHIELD D PLATE SPRING {izhu0/20} C,D,F,G,H, D I,J,K PLATE SPRING {izhu0/20} C,D,F,G,H, D I,J,K BCRS {izhu0/200} I BCRS {izhu20} I SOLID STATE SWITCH C SOLID STATE SWITCH (OPTION EXCEPT A) C SOLID STATE SWITCH (OPTION) C SOLID STATE SWITCH (METRIC) C SOLID STATE SWITCH (OPTION INCH) C SOLID STATE SWITCH A C SOLID STATE SWITCH (OPTION METRIC) C SOLID STATE SWITCH C SOLID STATE SWITCH (OPTION) C REED SWITCH C SHEET C SCREW C

24 OPTICAL SECTION 2 P 2 CCD 2 4 d d PC d d d d 2 d 6 4

25 OPTICAL SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts PLATE SPRING C TAPPING SCREW D LENS ASSY I d TENSION SPRING C PULLEY C PULLEY BRACKET( ) D SNS BRACKET D PHOTO INTERRUPTER B HINGE BRACKET(R ) D MOTOR B TENSION SPRING C MOTOR BRACKET D TIMING BELT C PULLEY C BALL BEARING B PULLEY C WIRE C COVER C SHAFT D PULLEY C

26 OPTICAL SECTION P 8 2 LA INV PC209

27 OPTICAL SECTION Pge. 8 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE BRACKET D XENON C REFLECTOR C PLATE SPRING D SLIDER C FFC CLAMP D PLATE SPRING D MIRROR C PWB ASSY C MIRROR C PULLEY C GUIDE D PLATE SPRING D BRACKET C TENSION SPRING C ARM C PHOTO INTERRUPTER B PHOTO INTERRUPTER ASSY C CUSHION C SCREW C CARRIAGE ASSY I CARRIAGE 2 ASSY C

28 POWER UNIT d 2 P HV M6 6 P/H e PU F F F

29 POWER UNIT Pge. 9 Key Prt No. Desription Destintions Clss QTY Stndrd prts BRACKET D COVER D HV TRANSFORMER I d DUCT D e BRACKET D FAN MOTOR C BRACKET D BRACKET D SHUTTER D TORSION SPRING C SHOULDER SCREW C TORSION SPRING C POWER SUPPLY {izhu0/20} C,D,F2,G,I I,J,K POWER SUPPLY A,B,F,G2,H I FERRITE CORE {izhu0/20} C,D,F,G,H, D I,J,K GUIDE C P/H ASSY {izhu0} I P/H ASSY {izhu20/200} I PRESSURE SPRING C SHOULDER SCREW C ELECTRICALLY CONDUCTIVE MATERIAL C SHIELD D SHIELD PLATE C BRACKET D ELECTRICALLY CONDUCTIVE MATERIAL {izhu0/20} C,D,F,G,H, C I,J,K REINFORCE PLATE D WIRE HARNESS ASSY D GUIDE {izhu0/20} C,D,F,G,H, C I,J,K FUSE A,B,F,G2,H C FUSE {izhu0/20} C,D,F2,G,I C,J,K FUSE A,B,F,G2,H C FUSE {izhu0/20} C,D,F2,G,I C,J,K FUSE {izhu0/20} C,D,F2,G,I C,J,K FUSE A,B,F,G2,H C

30 FRAME SECTION P S p n n d e g f 8 k k k k q p m e h g f 22 e

31 FRAME SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts HOLDER D RAIL D WIRE HARNESS ASSY D d CONTACT C e BRACKET D f STAY D g LABEL D h k HOLDER D 2 m STOPPER D 2 n BRACKET D p REINFORCE PLATE D q HARNESS A D RAIL D SPACER D REINFORCE PLATE D REINFORCE PLATE D BRACKET D RUBBER FOOT D REINFORCE PLATE D DUCT D SEAL C BRACKET D PIN C SHOULDER SCREW C BRACKET D EARTH GROUND C BRACKET D GUIDE D MICRO-SWITCH C BRACKET D GUIDE D TORSION SPRING C BRACKET D LABEL HI-VOL CAUTION D

32 FRAME SECTION P e h 8 S 2 6 d 20 g f

33 FRAME SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts CONTACT C HOLDER D PRESSURE SPRING C d EARTH GROUND D e CONTACT C f SEAL C g LABEL D h WIRE HARNESS ASSY D GUIDE PLATE D LEVER C SHAFT D MICRO SWITCH C JOINT C WIRE HARNESS ASSY D BRACKET D SHOULDER SCREW C CONTACT C LEVER C WIRE HARNESS ASSY D WIRE HARNESS ASSY D TENSION SPRING C LEVER D PLATE SPRING C GUIDE D LABEL HI-VOL CAUTION D CONTACT C CONTACT C SEAL C

34 PAPER TAKE-UP SECTION P d e PC PC d

35 PAPER TAKE-UP SECTION Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts REINFORCE PLATE D REINFORCE PLATE D REINFORCE PLATE D d FRAME D e WIRE HARNESS ASSY D BUSHING C ROLLER A CLUTCH C GEAR 2T C HOLDER D GEAR 29T C SHAFT D GUIDE C WEIGHT D GUIDE PLATE D COVER C SHAFT D TORSION SPRING C BUSHING C SHAFT D PRESSURE SPRING C JOINT C SHAFT D LEVER C TORSION SPRING C PHOTO INTERRUPTER B PIN C FRAME D GEAR 0T C ACTUATOR C

36 PAPER TAKE-UP SECTION P 20 e 8 g f k d f e h 4 m

37 PAPER TAKE-UP SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts GUIDE C GUIDE D GUIDE C d BRACKET D e TENSION SPRING C 2 f BRACKET D g PRESSURE SPRING C h-66 0 k BRACKET D m SHAFT D ROLLER C GUIDE D GUIDE D REINFORCE PLATE D BRACKET D SEPARATION ROLLER ASSY A GUIDE D HOLDER D SHAFT D GUIDE C LEVER C GUIDE C

38 PAPER TAKE-UP SECTION d 4 e CL2 9 e 2 P CL PC PC PC e PC

39 PAPER TAKE-UP SECTION Pge. 4 Key Prt No. Desription Destintions Clss QTY Stndrd prts GUIDE PLATE D BUSHING C PHOTO INTERRUPTER B d BRACKET D e FRAME D BRACKET D PIN D TORSION SPRING C ACTUATOR C COLLAR D ACTUATOR C BUSHING C ROLLER A CLUTCH C GEAR 0T C HOLDER D GEAR 29T C FRAME ASSY CLUTCH C GEAR 2T C SHAFT D PIN C SHAFT D TORSION SPRING C BUSHING C SHAFT D LEVER C TORSION SPRING C SHAFT D CLUTCH WASHER D GEAR T C SLEEVE D GEAR 26T C BRACKET D ROLLER C FRAME D

40 PAPER TAKE-UP SECTION P f d 6 g g g f g e d

41 PAPER TAKE-UP SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts DOOR C SEPARATION ROLLER ASSY A GUIDE C d LEVER C e PRESSURE SPRING C f BRACKET D g SHAFT D HOLDER D GUIDE D GUIDE C GUIDE D TENSION SPRING C BRACKET D BRACKET D GUIDE C GUIDE PLATE D GUIDE C GUIDE PLATE D TENSION SPRING C LEVER C BRACKET D HANDLE C PRESSURE SPRING C PRESSURE SPRING C ROLL C SHAFT D EARTH GROUND C LEVER C SCREW C REINFORCE PLATE D

42 BYPASS SECTION P d See P8 B See P A 6 e

43 BYPASS SECTION Pge. 6 Key Prt No. Desription Destintions Clss QTY Stndrd prts COVER D LABEL C LIFTING PLATE D d SEAL C 2 e SEAL C WEIGHT D HOLDER D REINFORCE PLATE D COLLAR C PRESSURE SPRING C TENSION SPRING C SEAL C GUIDE C GUIDE PLATE C BRACKET D BRACKET D HOLDER D SPACER C PRESSURE SPRING C SEPARATION ROLLER A CUSHION C GUIDE C GUIDE D TENSION SPRING C MANUAL FEED TRAY UNIT A S MANUAL FEED TRAY UNIT {izhu0/20} C,D,F,G,H, S I,J,K MANUAL FEED TRAY UNIT B,G2 S BRACKET D FRICTION SHEET C

44 BYPASS SECTION P A PC29 SL CL PC g e d f f h

45 BYPASS SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts LEVER C CAM C SHAFT D d HOLDER D e ACTUATOR C f TORSION SPRING C g HOLDER D h PIN D BRACKET D BUSHING C ROLLER A SHAFT D PHOTO INTERRUPTER B BRACKET D GUIDE C REINFORCE PLATE D HOLDER D GEAR 20/2T C BRACKET ASSY D GEAR 2T C GEAR 20T C BUSHING C GEAR 6/0T C CLUTCH C SOLENOID C HOLDER D SHIELD PLATE D DRUM D WASHER D MEMBER D BRACKET ASSY D BRACKET D CUSHION C RATCHET C TORSION SPRING B GEAR 0T C

46 BYPASS SECTION P 8 PC20 PC22 PC2 VR PC9 B e d 2 26

47 BYPASS SECTION Pge. 8 Key Prt No. Desription Destintions Clss QTY Stndrd prts BRAKE C REGULATING PLATE C COVER C d ACTUATOR C 4 e PHOTO INTERRUPTER B SHAFT D BRACKET D TORSION SPRING C TRAY C COVER C LABEL TRAY CAUTION B,C,D,F,G,H,I,J,K C LABEL A C TRAY C BRACKET D TORSION SPRING C HOLDER D STOPPER D BRACKET ASSY GEAR /8T C RACK C BRACKET D RESISTOR D HOLDER D REGULATING PLATE C BRAKE C SCALE METRIC {izhu0/20} C,D,F,G,H, D I,J,K SCALE METRIC A C SCALE INCH B,G2 C CLEANING PAD C TORSION SPRING C FERRITE CORE D COVER C COVER C

48 HOPPER SECTION P d 6

49 HOPPER SECTION Pge. 9 Key Prt No. Desription Destintions Clss QTY Stndrd prts JOINT C PRESSURE SPRING C COLLAR C d STOPPER {izhu0} B,C,D,F,G,H,I,J C,K STOPPER {izhu20/200} A D HANDLE C TORSION SPRING C HANDLE C STOPPER D TENSION SPRING C SEAL C SEAL C TENSION SPRING C SHUTTER D COLLAR D PRESSURE SPRING C PAWL C HOPPER UNIT {izhu0} B,G2 I HOPPER UNIT {izhu20/200} A I HOPPER UNIT {izhu0} A I HOPPER UNIT {izhu20/200} B,G2 I HOPPER UNIT {izhu0} C,D,F,G,I,J,H I HOPPER UNIT {izhu20} C,D,F,G,I,J,H I LABEL TONER TYPE {izh20/200} C LABEL TONER TYPE {izh0} C

50 HOPPER SECTION P 20 LA S h g g k e f e e m d 9

51 HOPPER SECTION Pge. 20 Key Prt No. Desription Destintions Clss QTY Stndrd prts GUIDE D GUIDE D STOPPER D d WIRE C e RAIL D f COVER D g TENSION SPRING C h k PLATE SPRING C m INCANDESCENT LAMP C SEAL C REGULATING PLATE C CONNECTOR 2P D SHUTTER D SEAL C PRESSURE SPRING C DUCT D 94 2 SWITCH C PLATE NUT D PIN D BUSHING C GEAR 28T C GEAR 4/9T C SCREW ASSY HOUSING D DETECTING PLATE D STIRRING PLATE ASSY MAGNET D HOLDER D SEAL C HOLDER D BRACKET D PLUG HOUSING D GUIDE D PLATE SPRING C SEAL C

52 DEVELOPING UNIT P UN2 2 d 4 I/C HEATER KIT (OPTION)

53 DEVELOPING UNIT Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts LID D PRESSURE SPRING C SHUTTER D d SEAL C SEAL C SEAL C SEAL C SEAL C SEAL C SEAL C SEAL C TONER FILTER A COVER C SEAL C PWB ASSY I DEVELOPING UNIT B HEATER KIT A S

54 PAPER TRANSPORT SECTION P C See P2 22 d 6 4 e M

55 PAPER TRANSPORT SECTION Pge. 22 Key Prt No. Desription Destintions Clss QTY Stndrd prts PAWL C BRACKET D RIGHT COVER D d COVER D e EARTH GROUND C BRACKET ASSY D SCREW C TORSION SPRING C PAWL C 40 0 PRESSURE SPRING C BRACKET D TERMINAL C GUIDE D FAN MOTOR C SEAL C BRACKET D SEAL C GEAR 2T C GUIDE C LABEL HI-TEMP CAUTION D TORSION SPRING C REINFORCE PLATE D INSULATING MEMBER C PAPER TRANSPORT UNIT S

56 PAPER TRANSPORT SECTION P 2 2 CL TH4 2 R PC C

57 PAPER TRANSPORT SECTION Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts TRANSFER ROLLER UNIT A PHOTO INTERRUPTER B BRACKET D RESISTOR D BUSHING C PRESSURE SPRING C CONTACT C CONTACT C CONTACT C HOLDER D GEAR 8T B BUSHING B GEAR T B TENSION SPRING C EARTH GROUND C ROLLER C 40 0 ROLLER C NEUTRALIZING NEEDLE D GUIDE C GUIDE C PRESSURE SPRING C THERMISTOR B WASHER C WASHER D CLUTCH C PRESSURE SPRING C ACTUATOR C TORSION SPRING C HOLDER D PAPER DUST REMOVER A

58 DRIVE SECTION P 24 f d 29 f M M e

59 DRIVE SECTION Pge. 24 Key Prt No. Desription Destintions Clss QTY Stndrd prts MOTOR B SHAFT D SHAFT D d BRACKET D e GEAR 2T C f GEAR 8T C GEAR 24T C GEAR 29/T C GEAR 28/49T C GEAR 26T C PLATE SPRING C LABEL D SPRING C SCREW C BRACKET ASSY D BRACKET ASSY D GEAR 29T C GEAR 20/6T C GEAR 2T C GEAR 2/T C BRACKET ASSY D GEAR 9/44T C GEAR 42T C GEAR 49T C GEAR 2/60T C GEAR 8/6T C GEAR 24/8T C GEAR 4T C DRIVE UNIT C

60 DRIVE SECTION 4 2 M 8 P 2 6 PWB-I PC PC PC M PC8 6 PWB-I2 PC PC6 PC PC4

61 DRIVE SECTION Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts HOLDER D LEVER C PWB-I C SHOULDER SCREW C PRESSURE SPRING C HOLDER D PHOTO INTERRUPTER B MOTOR B BRACKET D SHOULDER SCREW PRESSURE SPRING C HOLDER D BRACKET D BRACKET D BRACKET D 2

62 DRIVE SECTION P 26 CL SL SL g f e f d g 2 g g g g h g g

63 DRIVE SECTION Pge. 26 Key Prt No. Desription Destintions Clss QTY Stndrd prts CONNECTOR 2P D BUSHING C BRACKET ASSY d CLUTCH e BRACKET D f SHAFT D g SHAFT D h GEAR 9/T C PULLEY 28/6T C COLLAR C TIMING BELT 24L C BRACKET D BUSHING C PULLEY C 28 0 PULLEY C GEAR 0T C GEAR 24T C BRACKET ASSY D JOINT C PRESSURE SPRING C BRACKET D GEAR 24T C COVER D SOLENOID C BRACKET D SCREW C TENSION SPRING C SHAFT D GEAR 29T C GEAR /42T C GEAR /40T C GEAR 4T C SHAFT D GEAR 40T C GEAR 4/0T C SOLENOID C CONNECTOR 2P D BRACKET ASSY D SHOULDER SCREW C TENSION SPRING C GEAR /2T C GEAR 2T C BRACKET ASSY D GEAR ASSY PIN C SCREW C HOPPER DRIVE UNIT C

64 FUSING SECTION P 2 8 D See P28 d TH d TH2 d PC d

65 FUSING SECTION Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts SHOULDER SCREW C GUIDE D TORSION SPRING C d SHAFT D ROLL C TORSION SPRING C ACTUATOR C SEPARATOR C TENSION SPRING C SHAFT D PHOTO INTERRUPTER B HOLDER D LABEL HI-TEMP CAUTION D THERMAL INSULATOR C GUIDE PLATE D BRACKET D THERMISTOR KIT C FUSING UNIT 0V A B FUSING UNIT 20V B,G2,F B FUSING UNIT 20V {izhu0/20} C,D,F2,G,I B,J,K FUSING UNIT V {izhu0/20} H B

66 FUSING SECTION P D

67 FUSING SECTION Pge. 28 Key Prt No. Desription Destintions Clss QTY Stndrd prts ROLLER C ROLL C PROTECTION D BUSHING C GUIDE D STOPPER RING D HOLDER D SHAFT D ROLL C TORSION SPRING C SHAFT D ROLL C HOLDER D TORSION SPRING C GEAR 8T C BUSHING C NEUTRALIZING BRUSH D

68 ELECTRICAL COMPONENTS P 29 S M4 M TH g f f d g e 2

69 ELECTRICAL COMPONENTS Pge. 29 Key Prt No. Desription Destintions Clss QTY Stndrd prts BRACKET D COVER D BRACKET D d HOLDER D e DUCT D f OZONE FILTER A g CUSHION C CUSHION C DUCT D BRACKET D HOLDER D HUMIDITY CONVERTION EL. C BRACKET D WIRE HARNESS ASSY B,C,D,F,G,H,I,J,K D WIRE HARNESS ASSY A D BRACKET D SWITCH C BRACKET D SEAL C FILTER C GUIDE C DUCT D FAN MOTOR C COLLAR C 2

70 ELECTRICAL COMPONENTS 2 4 P 0 PWB-A PC 4 2

71 ELECTRICAL COMPONENTS Pge. 0 Key Prt No. Desription Destintions Clss QTY Stndrd prts EARTH GROUND C SHIELD D PWB-A I BRACKET D ELECTRICALLY CONDUCTIVE MATERIAL C BRACKET D PWB SUPPORT 6.4H D BRACKET C BRACKET D HOLDER D BRACKET {izhu0/20} C,D,F,G,H, D I,J,K BRACKET A,B,G2 D GUIDE C BRACKET D PHOTO INTERRUPTER B BRACKET D FERRITE CORE D

72 CASSETTE SECTION P d g f e

73 CASSETTE SECTION Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts EARTH GROUND C ACTUATOR C REGULATING PLATE D d GUIDE C e GUIDE C f WASHER D 2 g WASHER D BUSHING C REINFORCE PLATE D REGULATING PLATE D GUIDE D LABEL CARRYING CAPACITY D STOPPER C SHOULDER SCREW C GUIDE D GEAR 4T C REGULATING PLATE D KNOB D PRESSURE SPRING C LEVER D SHAFT D FRICTION SHEET C LIFTING PLATE D GUIDE C LEVER D SHAFT D BUSHING C LEVER C SHOULDER SCREW LABEL PAPER SUPPLY C FRONT COVER CASSETTE C LABEL CASSETTE CNT 2 C LABEL CASSETTE CNT C SHAFT D LABEL NEAR EMPTY C BRACKET D BRACKET D LEVER C STOPPER D CASSETTE D SCREW C HANDLE C CASSETTE ASSY S

74 TURNOVER UNIT P 2 M SL4 M PC d d d d e

75 TURNOVER UNIT Pge. 2 Key Prt No. Desription Destintions Clss QTY Stndrd prts DUCT D DUCT D DOOR D d SHAFT D e SHOULDER SCREW D COLLAR D LABEL D GUIDE D SEAL C SEAL C SEAL C GUIDE D TORSION SPRING C ACTUATOR C BUSHING C GUIDE D PHOTO INTERRUPTER B PLATE SPRING C ROLL C COLLAR D GEAR C BUSHING D GEAR C WIRE HARNESS ASSY D MOTOR C TENSION SPRING C NEUTRALIZING BRUSH D COVER D ROLLER C COLLAR C FRAME D EARTH GROUND C COVER D GUIDE D FAN MOTOR C TORSION SPRING C TORSION SPRING C GUIDE D GUIDE D GUIDE D PIN C

76 DUPLEX UNIT 24 P PC PC PC

77 DUPLEX UNIT Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts LEVER C LABEL C PRESSURE SPRING C COVER D PIN D EARTH GROUND D EARTH GROUND C SHOULDER SCREW C BASE FRAME D COVER D MEMBER C ROLL C GUIDE D GUIDE D TORSION SPRING C ACTUATOR C BRACKET D PHOTO INTERRUPTER B BRACKET D GUIDE D ACTUATOR C TORSION SPRING C BRACKET D BASE FRAME D WASHER D PRESSURE SPRING C GUIDE D 2

78 DUPLEX UNIT P 4 CL6 CL

79 DUPLEX UNIT Pge. 4 Key Prt No. Desription Destintions Clss QTY Stndrd prts BUSHING C ROLLER C ROLL C ROLLER C ROLLER C BRACKET D WIRE HARNESS ASSY D EARTH GROUND D PULLEY C PULLEY C BRACKET ASSY D PULLEY C GEAR C COLLAR D TIMING BELT C ROLL C CLUTCH TIMING BELT C PULLEY C GEAR C GEAR C GEAR C GEAR C TORSION SPRING C LEVER ASSY C MEMBER C 4

80 WIRING P S2-NO CN9 (CABINET) CORE S2-COM CN4 (CL) PJ6PU PJA 2 PJA CN42 (M) PJ (PC) CN82 (TH4) PJ24A PJ2A PJ42 (M) PJ (PC) PJ (PC) PJ8 (PC8) PJ (PC) PJI

81 WIRING Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY D WIRE HARNESS ASSY D WIRE HARNESS ASSY D

82 WIRING P 6 CN46(BL) (CL2) CN48 (CL4) CN28 PJ2 (PC2) PJ (PC) CN2 PJ (PC) PJ2 (PC2) 2 PJ4 (M8) PJ (PC) PJ (PC) PJ4 (PC4) PJ6 (PC6) PJI2 PJ2A PJ26A

83 WIRING Pge. 6 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY D WIRE HARNESS ASSY D

84 WIRING CN CN2 GND CN49 CN4 PJ29 P CN GND8 PJ9 PJ22 2 CN PJ20 PJ2 CN80 (TH) PJ4 (PC4) PJ8 (PC8) CN0

85 WIRING Pge. Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY D WIRE HARNESS ASSY D WIRE HARNESS ASSY D

86 WIRING P 8 PJA PJ8PU (PU) CN (ADF) PJ9A 2 PJBCR PJ2BCR PJ2PU2 CORE PJPU

87 WIRING Pge. 8 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY D WIRE HARNESS ASSY D

88 WIRING CN2 PJ4A PJA PJ4A CN CN6 (M) CN P 9 PJA CN24 (CNT) CN26 PJHV CN4 (M6) PJ (PC) 2 PJA PJMFB

89 WIRING Pge. 9 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY {izhu0} D WIRE HARNESS ASSY {izhu20} D WIRE HARNESS ASSY {izhu200} D WIRE HARNESS ASSY D

90 WIRING P 40 CN2 CN0 CN CN28 CN4 CN2 CN2 PJ62 (TH) PJ4 (M2) PJ40 (M) CN8 (TH2) CN CN44 (M) CN CN4 CN2 CN0 PJ8A PJ2A PJ28A PJ20A PJ2A PJ9A PJ4A PJ29A PJ2A PJA PJ8A PJ6A PJ4PU CN20 CN8 PJ2A PJ22A CN2 CN-CHV PJ-CHV 2

91 WIRING Pge. 40 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY {izhu0/20} D WIRE HARNESS ASSY {izhu200} D WIRE HARNESS ASSY D

92 WIRING P 4 CN4 (BCRS) (PC204) (PC208) (PC209) 2 CN (BCRS) (PC202) CN (INV) (PC20) (PC20) CN (BCRS) CN9 (BCRS) (PWB-O) 4 CN6 (BCRS) (PC20) (PC206) (PC20)

93 WIRING Pge. 4 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRE HARNESS ASSY D WIRE HARNESS ASSY D WIRE HARNESS ASSY D WIRE HARNESS ASSY D WIRE HARNESS ASSY (OPTION) D

94 WIRING ACCESSORIES AND JIGS P T= T= L=4

95 WIRING ACCESSORIES AND JIGS Pge. 42 Key Prt No. Desription Destintions Clss QTY Stndrd prts WIRING SADDLE D WIRING SADDLE 2.H D WIRING SADDLE 4.4H D WIRING SADDLE 9.2H D WIRING SADDLE.H D WIRING SADDLE 8.H D CORD CLAMP D CORD CLAMP D CORD CLAMP D CABLE TIE 4L D EDGE COVER D EDGE COVER D EDGE COVER 8.H D INSULATING MEMBER D INSULATING MEMBER D CN COVER D SPACER (WHITE) C SPACER (BLACK) C JIG MEMORY CARD (MSC) A S JIG MEMORY CARD (MSC) B,G2 S JIG MEMORY CARD (MSC) {izhu0/20} C S JIG MEMORY CARD (MSC) {izhu0/20} J,H S JIG MEMORY CARD (MSC) {izhu0/20} D,F,G,I,K S JIG MEMORY CARD (ENGINE) S JIG THERMISTOR S

96 ACCESSORY PARTS P

97 ACCESSORY PARTS Pge. 4 Key Prt No. Desription Destintions Clss QTY Stndrd prts P-CLIP D D LABEL METRIC A,C,D,F,G,H,I,J,K C LABEL INCH B,G2 C HOLDER C COVER C LABEL C POWER CORD {izhu0/20} D,F2,G,I,K C POWER CORD B,G2 C POWER CORD {izhu0/20} H C POWER CORD {izhu0/20} J C POWER CORD A C

98 MAINTENANCE LIST The items with no Pge/Key numers re not hndled s spre prts. / No. Setion PM Prts Desription Mintenne Cyle (K=,000) Prts No. Destintions Pge/Key Note QTY Reple Bypss Feed Roller 00K 400 P- 2 Seprtion Roller Assy 00K 4040 P6-20 Try Feed Roller 00K P2- *4 4 Pik-up Roller 00K P2- *4 Seprtion Roller Assy 00K 4000 P- *4 6 Try 2 Feed Roller 00K P4- *4 Pik-up Roller 00K P4- *4 8 Seprtion Roller Assy 00K 4000 P-2 *4 9 Conveyne Setion Registrtion Roller Bering 4 900K P2-2 Registrtion Roller Ger 900K P2- T = 8 Registrtion Roller Ger 2 900K 640 P2- T = 2 Pper Dust Remover 0K P2-0 Fusing Setion Fusing Unit 40K A P2-8 0V 4 Fusing Unit 40K B,G2,F P2-8 20V Fusing Unit 40K C,D,F2,G,I,J,K P2-8 20V 6 Fusing Unit 40K H P2-8 V Trnsfer Setion Trnsfer Roller Unit 0K P2-8 Proess Setion Photo Condutor Unit 0K - izhu 0 - *2 9 80K - izhu 20 - *2 20 6K - izhu *2 2 Developer 0K - izhu K - izhu K - izhu Developing Unit 400K izhu 0 P2-6 * 2 20K izhu 20 P2-6 * K izhu 200 P2-6 * 2 Toner Filter (Developing Unit) 0K izhu 0 P2-2 * K izhu 20 P2-2 *2 29 6K izhu 200 P2-2 *2 0 Toner Filter (Min Unit) 400K izhu 0 P2-2 * 20K izhu 20 P2-2 * 2 260K izhu 200 P2-2 * Ozone Filter 00K 4020 P29-6 *: Mintenne Cyle is the Speil Prts Counter vlue. *2: The Photo Condutor Unit nd Toner Filter (Developing Unit) should e repled with new ones t the some time. *: The Developing Unit nd Toner Filter (Min Unit) should e repled with new ones t the sme time. *4: Reple those three prts t the sme time.

99 DESTINATION Destintion No. Destintions V Hz Model No. A D F G A JAPAN 0 0/60 A2 JAPAN B USA, CANADA C EUROPEAN TYPE /60 E D S.EASIATYPE THAILAND, SRI LANKA, SINGAPORE, MALAYSIA, HONG KONG, PAKISTAN, INDIA, BANGLADESH, INDONESIA /60 D OCEANIA TYPE AUSTRALIA, NEW ZEALAND /60 PHILIPPINES F SAUDI ARABIA 2 60 F2 SAUDI ARABIA /60 G C.S AMERICA /60 G2 C.S AMERICA H TAIWAN /404/ /404/ /4289/ / / / / / / /404/ /404-

100 Destintion No. Destintions V Hz Model No. I JORDAN,LEBANON,SYRIA,SOUTHAFRICA,IRAQ,IRAN,N.YEMEN,CAME- ROON, UAE, BAHRAIN, OMAN, QATAR, KUWAIT, KENYA, TUNISIA, IVORY COAST, MOROCCO / / J CHINA /60 K KOREA / / / /22/200