Cat Electronic Technician 2014A v1.0 Product Status Report 10/23/2016 9:09 AM Product Status Report Parameter Engine Serial Number Equipment ID Comments Value DSE00164 78M-9-P RUNNING OF NOS.3 ENGINE AFTER OVERHAUL ON 23/10/2016 @0905 HRS ON OCEAN GLORY C18 Marine Genset #1 (DSE00164) Parameter Value Equipment ID 78M-9-P Engine Serial Number DSE00164 ECM Serial Number 04946101JV Software Group Part Number 4472902-00 Software Group Release Date OCT13 Software Group Description C18-MarAuxACERT-A4 Logged Diagnostic Codes [Diagnostic Clock = 4712.1829 hours] - C18 Marine Genset #1 (DSE00164) Code Description Occ. First Last 91-8 Throttle Position Sensor : Abnormal Frequency, 2 4700 4711 Pulse Width, or Period Logged Event Codes [Diagnostic Clock = 4712.1829 hours] - C18 Marine Genset #1 (DSE00164) Code Description Occ. First Last E096 (1) High Fuel Pressure 1 4712 4712 E105 (2) Turbocharger Turbine Inlet Air High 127 1465 4712 E190 (1) Engine Overspeed Warning 1 4712 4712 E190 (3) Engine Overspeed Warning 1 4712 4712 E198 (1) Low Fuel Pressure 1 4712 4712 E552 (1) Low Aftercooler Coolant Level 32 4654 4711 Active Diagnostic Codes - C18 Marine Genset #1 (DSE00164) Code No Active Codes Description Active Event Codes - C18 Marine Genset #1 (DSE00164) Code Description
No Active Events Current Totals - C18 Marine Genset #1 (DSE00164) Description Value Unit Total Time 4712 hours Total Fuel 57659 gal Average Fuel Rate Based Percent Engine Load Factor 25 % Configuration - C18 Marine Genset #1 (DSE00164) Description Value Unit Equipment ID 78M-9-P Engine Serial Number DSE00164 ECM Serial Number 04946101JV Software Group Part Number 4472902-00 Software Group Release Date OCT13 Software Group Description C18-MarAuxACERT-A4 Rating Number 1 Rated Frequency 60 Hz Rated Engine Speed 1800 rpm Rated Power 738 hp at 1800 rpm Rating Configuration Low Emissions Test Spec 0K0000 Engine Location Engine #1 Engine Acceleration Rate 500 rpm/s Crank Terminate RPM 400 rpm Low Idle Speed 1200 rpm Engine Speed Droop 0.0 % Droop/Isochronous Switch Enable Enabled Droop Mode Selection Externally Requested Isochronous Remote Throttle Control Ramp Rate 10 rpm/s Desired Speed Input Configuration PWM Secondary Desired Speed Input PWM Configuration Emergency Shutdown Override Input Switch to Ground Configuration Emergency Shutdown Override Switch Not Installed Remote Throttle Control Install Installed Coolant Level Sensor Installed Aftercooler Coolant Level Sensor Installed Unfiltered Engine Oil Pressure Sensor Not Installed Unfiltered Fuel Pressure Sensor Installation Not Installed Status Engine Coolant Pressure Sensor Not Installed
Exhaust Sensor Installation Not Installed Status Engine Oil Sensor Installation Not Installed Status Engine Oil Level Sensor Not Installed High Exhaust Warning Disabled System Enable Status Engine Oil Capacity 19.0 gal Maintenance Indicator Mode Off PM1 Interval 0 gal Governor Gain Factor #1 11534 Governor Minimum Stability Factor #1 1049 Governor Maximum Stability Factor #1 2097 FLS 24 FTS 0 Total Tattletale 14 Lifetime: Time vs Engine Coolant - C18 Marine Genset #1 (DSE00164) Engine Coolant ( hours % Deg F ) <122 4.10 0.09 122-130 3.80 0.08 131-139 4.55 0.10 140-148 5.35 0.11 149-157 51.35 1.09 158-166 1728.35 36.74 167-175 1876.65 39.90 176-184 871.80 18.53 185-193 121.75 2.59 194-202 31.55 0.67 203-211 4.20 0.09 212-220 0.35 0.01 221-229 0.00 0.00 230-238 0.00 0.00 239-247 0.00 0.00 >248 0.00 0.00 Lifetime: Time vs Inlet Air - C18 Marine Genset #1 (DSE00164) Inlet Air ( Deg F ) hours % <104 0.00 0.00 104-112 0.00 0.00 113-121 0.00 0.00 122-130 0.15 27.27 131-139 0.15 27.27 140-148 0.25 45.45 149-157 0.00 0.00 158-166 0.00 0.00 167-175 0.00 0.00 176-184 0.00 0.00
185-193 0.00 0.00 194-202 0.00 0.00 203-211 0.00 0.00 >212 0.00 0.00 Lifetime: Time vs Boost Pressure - C18 Marine Genset #1 (DSE00164) Boost Pressure( psi ) hours % <12 0.00 0.00 12-12 0.00 0.00 13-14 0.00 0.00 15-15 0.00 0.00 16-16 0.00 0.00 17-18 0.00 0.00 19-19 0.00 0.00 20-21 0.00 0.00 22-22 0.00 0.00 23-24 0.00 0.00 25-25 0.00 0.00 26-27 0.00 0.00 28-28 0.00 0.00 >29 0.65 100.00 Lifetime: Time vs Engine Speed And Engine Load Factor - C18 Marine Genset #1 (DSE00164) rpm <1100 1100-1300- 1500-1700- 1900-2100- >2300 Total 1299 1499 1699 1899 2099 2299 % <50 0.00 0.00 0.00 0.00 99.61 0.00 0.00 0.00 99.61 50-60 0.00 0.00 0.00 0.00 0.03 0.00 0.00 0.00 0.03 60-70 0.00 0.00 0.00 0.00 0.05 0.00 0.00 0.00 0.05 70-80 0.00 0.00 0.00 0.00 0.05 0.00 0.00 0.00 0.05 80-90 0.00 0.00 0.00 0.00 0.23 0.00 0.00 0.00 0.23 >90 0.00 0.00 0.00 0.00 0.03 0.00 0.00 0.00 0.03 Total 0.00 0.00 0.00 0.00 99.99 0.00 0.00 0.00 100.00 Lifetime: Total Occurrences vs Engine Speed - C18 Marine Genset #1 (DSE00164) Engine Speed( rpm ) % <2500 40.00 85.11 2500-2599 3.00 6.38 2600-2699 2.00 4.26 2700-2799 2.00 4.26 2800-2899 0.00 0.00 2900-2999 0.00 0.00 3000-3099 0.00 0.00 3100-3199 0.00 0.00 3200-3299 0.00 0.00 >3300 0.00 0.00 Lifetime: Time vs Turbo Inlet And Inlet Air - C18 Marine Genset #1
(DSE00164) Deg F <104 104-112 113-121 122-130 131-139 >140 Total Deg F <140 0.00 0.00 88.36 11.64 0.00 0.00 100.00 140-149 0.00 0.00 0.00 0.00 0.00 0.00 0.00 149-158 0.00 0.00 0.00 0.00 0.00 0.00 0.00 158-167 0.00 0.00 0.00 0.00 0.00 0.00 0.00 167-176 0.00 0.00 0.00 0.00 0.00 0.00 0.00 >176 0.00 0.00 0.00 0.00 0.00 0.00 0.00 Total 0.00 0.00 88.36 11.64 0.00 0.00 100.00 Lifetime: Time vs Fuel Pressure - C18 Marine Genset #1 (DSE00164) Fuel Pressure( psi ) hours % <73 25.55 0.54 73-74 551.70 11.73 75-77 0.80 0.02 78-80 0.90 0.02 81-83 1.05 0.02 84-86 1.60 0.03 87-89 2.05 0.04 90-92 1.85 0.04 93-95 9.35 0.20 96-98 12.80 0.27 99-101 22.05 0.47 102-103 9.95 0.21 104-106 3.85 0.08 >107 4060.55 86.32 Injector Trim Calibration - C18 Marine Genset #1 (DSE00164) Injector Serial Number File Version Injector1 000000005A530234388F 0 Injector2 000000005A53023461F1 0 Injector3 000000005A53023421A5 0 Injector4 000000005A53009349AD 0 Injector5 000000005A53013906AD 0 Injector6 000000005A53009301C1 0 Monitoring System - C18 Marine Genset #1 (DSE00164) Description State Trip Point Delay Time Engine Overspeed Least Severe (1) Always On 1980 rpm 0 sec Most Severe (3) Always On 2070 rpm 0 sec High Engine Coolant Least Severe (1) Always On 216 Deg F 30 sec Moderate Severity (2) On 225 Deg F 30 sec Most Severe (3) Off 230 Deg F 30 sec
High Engine Inlet Air Least Severe (1) On 158.0 Deg F 30 sec Moderate Severity (2) Off 174.2 Deg F 30 sec High Engine Oil Least Severe (1) On 221 Deg F 5 sec Moderate Severity (2) Off 239 Deg F 15 sec Most Severe (3) Off 239 Deg F 30 sec High Exhaust Least Severe (1) Off 1274 Deg F 5 sec High Fuel Filter Restriction Pressure Least Severe (1) On 20 psi 30 sec High Fuel Pressure Least Severe (1) On None 2 sec Moderate Severity (2) On None 30 sec Most Severe (3) Off None 30 sec High Fuel Least Severe (1) Always On 194.0 Deg F 30 sec Moderate Severity (2) Off 195.8 Deg F 30 sec Most Severe (3) Off 197.6 Deg F 30 sec High Oil Filter Differential Pressure Least Severe (1) On 16 psi 30 sec Low Aftercooler Coolant Level Least Severe (1) On None 30 sec Moderate Severity (2) Off None 30 sec Most Severe (3) Off None 30 sec Low Coolant Level Least Severe (1) On None 30 sec Moderate Severity (2) Off None 30 sec Low Engine Coolant Pressure Least Severe (1) On None 10 sec Moderate Severity (2) On None 130 sec Low Engine Oil Level Least Severe (1) On None 30 sec Moderate Severity (2) Off None 30 sec Low Engine Oil Pressure Least Severe (1) Always On None 8 sec Moderate Severity (2) On None 8 sec Most Severe (3) Off None 4 sec Low Fuel Level Least Severe (1) Off 13 % 300 sec Low Fuel Pressure Least Severe (1) On None 2 sec
Moderate Severity (2) Off None 30 sec Most Severe (3) Off None 30 sec Bridge Color MPD -Starbrd Parameter Value ECM Part Number 292-971301 ECM Serial Number 1294G001MU Software Group Part Number 306-306100 Software Group Release Date Software Group Description Configuration - Bridge Color MPD -Starbrd Description Value Unit Display Location Bridge Engine Location Starboard