Parts Manual Generator Set with Detector /-Wire Remote Control GGDB (Spec A E) English 0 00 0 (Issue )
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-
Introduction This parts catalog applies to the Cummins Power Generation standard generator model GGDB as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding with the same reference number in the parts list. Parts illustrations are typical. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set. Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All other engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturers nameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement parts. Replacement Engine Cummins Power Generation Generator Model GGDB Ford Engine Model LRGI 00 A Replacement engines cannot be ordered from Cummins Power Generation. Order from your nearest Ford Distributor. Generator Set Data Table Model/ Electrical Data Battery Specification Watts Volts Hertz Wire Phase Voltage.0GGDB*,000 # 0,, or VDC 0.0GGDB* 0,000 # 0,, or VDC * The specification number denotes customer requested options or deviations from the Standard model. The specification letter advances with major manufacturing changes. # Broad Range Reconnectible.
Index A Adapter, Duct, Adapter, Generator, Ammeter, AC Sets With Detector Control, Armature, Starter, B Baffle, Air Generator Begin Spec E, Baffle, Air Generator Spec A D, Battery, Hold Down Begin Spec E, Battery, Hold Down Skid Spec A D, 0 Bearing, Starter (Commutator End), Bearing, Starter (Pinion End), Bell, End Generator Begin Spec E, Bell, End Generator Spec A D, Block, Terminal Control Box Sets With Wire Control, Block, Terminal Control Box Sets With Detector Control, Block, Terminal Control Harness Sets With Wire Control, Block, Terminal Control Housing Sets With Detector Control, Block, Terminal Engine to Control Wiring Harness Sets With Detector Control Begin Spec D, Block, Terminal Engine to Control Wiring Harness Sets With Detector Control Spec A C, Board, Connection Generator Begin Spec E, Board, Connection Generator Spec A D, Board, Printed Circuit Engine Monitor Sets With Detector Control, Board, Printed Circuit Overspeed Sets With Wire Control, Board, Printed Circuit Sensor Board Sets With Detector Control, Board, Printed Circuit Voltage Regulator, 0 Box, Control Sets With Wire Control, Box, Control Sets With Detector Control, Brace, Radiator Begin Spec B, Brace, Radiator Spec A, Bracket, Air Cleaner Muffler, Bracket, Battery Guard, Bracket, Control Saddle, Bracket, Coolant Tank, Bracket, Front Engine Mounting Skid, 0 Bracket, Heater Coolant Heater, Bracket, Mounting Circuit Breaker Sets With Wire Control, Bracket, Mounting Circuit Breaker Sets With Detector Control, Bracket, Overspeed Sets With Wire Control, Bracket, Overspeed Switch Sets With Detector Control, 0 Breaker, Circuit Control Box Sets With Wire Control, Breaker, Circuit UL Listed Begin Spec B, Breaker, Circuit UL Listed Spec A, Breaker, Circuit UL Listed, IEC Conformity Begin Spec B, Breaker, Circuit UL Listed, IEC Conformity Spec A, Breaker, Circuit Voltage Regulator, 0 Breather, Air Cleaner Spec A, B, C Cable, Battery, Cable, Heater Control, Cap, Radiator Begin Spec B, Cap, Radiator Spec A, Cap, Tank Coolant Tank, Cleaner, Air Begin Spec C, Cleaner, Air Spec A, B, Clutch, Starter, Contact, Auxiliary Switch Begin Spec B,
Index Contact, Auxiliary Switch Spec A, Contact, Dry Begin Spec B, Control, Wire, Control, Detector, Cord, Heater Generator Heater, Cover, Air Cleaner Spec A, B, Cover, Battery Begin Spec E, Cover, Circuit Breaker Sets With Wire Control, Cover, Circuit Breaker Sets With Detector Control, Cover, Control Box Sets With Wire Control, Cover, Control Door Sets With Detector Control Begin Spec E, Cover, Control Housing Sets With Detector Control, Cover, End Bell, Cushion, Mounting Skid, 0 Cushion, Vibration Isolation Skid, 0 D Disk, Rotor Drive Generator Begin Spec E, Disk, Rotor Drive Generator Spec A D, Door, Control Sets With Detector Control, Drain, Radiator, E Element, Air Cleaner Begin Spec C, External Engine Parts, F Fan, Engine Begin Spec B, Fan, Engine Spec A, Fan, Generator Begin Spec E, Fan, Generator Spec A D, Filter, Air Spec A, B, Filter, Oil, Frame, Starter (Commutator End), Fuel System, Natural Gas, Fuel System, Natural Gas With Low Fuel Pressure Warning Switch Begin Spec B, Fuel System, Natural Gas/Propane Liquid With Low Pressure Switch and Automatic Changeover, Fuel System, Natural Gas/Propane Vapor With Low Pressure Switch and Automatic Changeover, 0 Fuel System, Propane Liquid, Fuel System, Propane Vapor, Fuel System, Propane Vapor With Low Fuel Pressure Warning Switch Begin Spec B, Fuse Control Box Sets With Wire Control, Fuse Control Box Sets With Detector Control, G Gasket, Air Cleaner Spec A, B, Gauge, Oil Pressure Sets With Wire Control Engine Mounted, Gauge, Oil Pressure Sets With Detector Control Control Mounted, Gauge, Water Temperature Sets With Wire Control Engine Mounted, Gauge, Water Temperature Sets With Detector Control Control Mounted, Generator (Assembly) Begin Spec E, Generator (Assembly) Spec A D, Governor Begin Spec D, Governor Spec A C, Grille, Air Outlet Engine, Guard, Alternator Belt Radiator Begin Spec B, Guard, Alternator Belt Radiator Spec A, Guard, Alternator Belt Remote Radiator, Guard, Belt Remote Radiator, Guard, Fan Radiator Begin Spec B,
Index Guard, Fan Radiator Spec A, Guard, Radiator Begin Spec B, Guard, Radiator Spec A, H Hanger, Tank Coolant Tank, Harness, Wiring AC Auxiliary Sets With Detector Control Begin Spec D, Harness, Wiring AC Auxiliary Sets With Detector Control Spec A C, Harness, Wiring AC Control Door Sets With Detector Control, Harness, Wiring Control Box Sets With Wire Control, Harness, Wiring DC Control Door Sets With Detector Control, Harness, Wiring Dry Contact Begin Spec B, Harness, Wiring Dual Fuel Natural Gas/Propane Vapor With Low Pressure Switch and Automatic Changeover, 0 Harness, Wiring Dual Fuel Natural Gas/Propane Liquid With Automatic Changeover, Harness, Wiring Engine to Control Sets With Wire Control Begin Spec D, Harness, Wiring Engine to Control Sets With Wire Control Spec A C, Harness, Wiring Engine to Control Sets With Detector Control Begin Spec D, Harness, Wiring Engine to Control Sets With Detector Control Spec A C, Harness, Wiring Ignition, Harness, Wiring Terminal Block Sets With Detector Control, Harness, Wiring Vacuum Switch, Heater, Control, Heater, Engine Coolant, Heater, Generator, Hose, Air Cleaner Begin Spec C, Hose, Breather Air Cleaner Spec A, B, Hose, Engine Coolant Radiator Begin Spec B, Hose, Engine Coolant Radiator Spec A, Hose, Radiator Begin Spec B, Hose, Radiator Remote Radiator, Hose, Radiator Spec A, Hose, Radiator Drain, Housing, Air Cleaner Spec A, B, Housing, Control Detector Control, Housing, Generator Set Quiet Site Second Stage Begin Spec B, Housing, Generator Set Standard Weather Protective, Housing, Starter, I Isolator, Vibration Control Box Sets With Wire Control, Isolator, Vibration Control Box Sets With Detector Control, J Joint, Ball Governor Begin Spec D, Joint, Ball Governor Spec A C, K Kit, Starter Brush, L Lever, Governor Begin Spec D, Lever, Governor Spec A C, Light, Indicator Sets With Detector Control, M Meter, Frequency Sets With Detector Control, Meter, Hour Sets With Wire Control,
Index Meter, Hour Sets With Detector Control, Module, Ignition Begin Spec D, Module, Ignition Spec A, B, Module, Ignition Spec C, 0 Mount, Radiator Begin Spec B, Mount, Radiator Spec A, Muffler, Critical, O Overspeed, Electronic Sets With Wire Control, Paint, P Panel, Control Box Sets With Wire Control, Panel, Control Housing Sets With Detector Control, Pickup, Magnetic Governor Begin Spec D, Pickup, Magnetic Governor Spec A C, Point, Overspeed Sets With Detector Control, 0 Potentiometer Voltage Regulator, 0 R Radiator Begin Spec B, Radiator Spec A, Radiator, Remote, Rectifier Control Harness Sets With Wire Control, Rectifier Generator Begin Spec E, Rectifier Generator Spec A D, Rectifier, Power Control Heater, Regulator, Voltage Sets With Wire Control, Regulator, Voltage Sets With Detector Control, 0 Relay Control Box Sets With Wire Control, Relay Control Harness Sets With Wire Control, Relay Dry Contact Begin Spec B, Relay Engine to Control Wiring Harness Sets With Detector Control Begin Spec D, Relay Engine to Control Wiring Harness Sets With Detector Control Spec A C, Relay, Timer Sets With Wire Control, Rotor, Exciter Begin Spec E, Rotor, Exciter Spec A D, Rotor, Generator Begin Spec E, Rotor, Generator Spec A D, Rotor, Ignition Overspeed Sets With Wire Control, S Sealant, Thread, Sender, Oil Pressure Sets With Detector Control, Sender, Water Temperature Sets With Detector Control, Shield, Exhaust Engine, Shield, Heat Muffler, Shroud, Fan Radiator Begin Spec B, Shroud, Fan Radiator Spec A, Skid, 0 Starter, Stator, Exciter Begin Spec E, Stator, Exciter Spec A D, Stator, Generator Begin Spec E, Stator, Generator Spec A D, Strap, Electrical Engine, Strap, Ground Control Box Sets With Detector Control, Switch, Low Coolant Level, Switch, Oil Pressure Sets With Wire Control, Switch, Overspeed Sets With Detector Control, 0
Index Switch, Rocker Control Box Sets With Wire Control, Switch, Rocker Control Box Sets With Detector Control, Switch, Starter, Switch, Vacuum, T Tank, Coolant, Thermostat Sets With Wire Control, Trip, Shunt Begin Spec B, Trip, Shunt Spec A, Tube, Exhaust Muffler, V Voltmeter, AC Sets With Detector Control, Voltmeter, DC Sets With Detector Control,
Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG Deg DC EFC ET EIT GFI ID IT IEC kw LPG LT M(meter Number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Degree Direct Current Electronic Fuel Control External Tooth External/Internal Tooth Ground Fault Interrupter Inside Diameter Internal Tooth International Electrotechnical Commission Kilowatt Liquid Petroleum Gas Left Meter mm MOH NFS NPT OD oz. PMG Ph PC RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Permanent Magnet Generator Phase Printed Circuit Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With Paint and Thread Sealant Onan Green Enamel (Non-Metallic) 00 oz. Pressurized Spray Can 00 Quart Can 00 Gallon Can 00 Sealant, Thread ( ml. Tube)
External Engine Parts H0,H,H0 0 0 0 0
External Engine Parts 0 0 Plate, Engine Rear 0 Flywheel (Includes Ring Gear) 0 Gear, Ring Tube, Exhaust 0 00 Washer, Lock Spring 00 0 Screw, Cap Hex Head (M0 x. x mm) 0 Adapter, Generator 0 0 0 Adapter, Oil Drain 0 00 Valve, Shut Off (/ x / ) 0 0 0 Barb, Hose (/ x / Hose) 0 00 Hose (/ ID) Bulk (Order by the Foot Foot Required) 0 0 Clamp, Hose 0 0 Washer, Flat (M0) 00 0 Screw, Cap Hex Head (M0 x. x mm) Clamp, J 000 Washer, Lock ET (M0) 00 0 Screw, Cap Hex Head (M0 x. x 0mm) 00 0 Screw, Cap Hex Head (M0 x. x 0mm) 0 Cable, Battery (Negative) 0 0 Cable, Battery (Positive) 000 Strap, Electrical Shield, Exhaust Washer, End Bell Clamp, Muffler (. OD Tube) Fitting, Water Temperature 0 0 Thermostat Generator Sets With -Wire Control 0 Sender, Water Temperature Generator Sets With Detector Control 0 000 Bushing, Reducer (/ to / ) Fitting, Oil Pressure 0 0 Switch, Oil Pressure Generator Sets With -Wire Control (S) 0 Sender, Oil Pressure Generator Sets With Detector Control (Includes Parts Marked +) (E) + Connector, Receptacle Place + Wedge, Receptacle 0 + Socket, Contact 0 Grille, Air Outlet 0 00 Screw, Set Socket Head (/ 0 x /) Spec A D 0 00 Plug, Pipe 00 0 Screw, Cap Hex Head (M x. x mm) Spec A D 0 00 Washer, Lock Spring (M) Spec A D 0 00 Nut, Hex (M x.) Spec A D 0 Boot, Battery Red 0 Bracket, Battery Guard Fitting 0 00 Plug, Square (/) Spec A, B Fitting, Vacuum Ford Part Number P&A ETZ A C Spec C D 0 0 0 Nut, Hex Flange 0 0 Bushing, Reducer (/ x /) Begin Spec B 0 Washer, Flat (#0) Spec A D 0 0 Vent, Air Begin Spec B 0 00 Cock, Drain Spec A 0 Module, Ignition Spec A, B (Spec C Ignition Module shown on page 0 Begin Spec D Ignition Module shown on page ) Harness, Wiring Ignition 0 Spec A, B 0 Spec C Begin Spec D 0 Boot, Starter Red Begin Spec E LF0 Filter, Oil + Parts Included In 0 Oil Pressure Sender
Ignition Module Spec C 0 Module, Ignition 0 0 Screw, Hex Flange Head Thread Forming (M x 0. x ) 0 00 Washer, Lock Spring (M) 0 00 Nut, Hex (M x 0.) 0 Hose, Vacuum 00 00 Screw, Cap Hex Head (M x 0. x 0) 0
Ignition Module Begin Spec D 0 0 0 Module, Ignition 00 0 Screw, Hex Flange Head Thread Forming (M x 0. x ) 0 00 Washer, Lock Spring (M) 0 0 00 Nut, Hex (M x 0.)
Air Cleaner Spec A, B 0 0 0 Housing, Air Cleaner 0 0 Cover, Air Cleaner 0 0 Stud (/ 0 x.) 0 Filter, Air 000 Nut, Wing (/ 0) 000 Nut, Wing (/ 0) 0 Breather, Air Cleaner 0 Plug, Hole 0 0 Gasket, Air Cleaner 0 0 0 Hose, Breather Bulk (Order By The Foot Feet Required)
Air Cleaner Begin Spec C 0 0 Cleaner, Air 0 Element, Air Cleaner 0 0 Hose, Air Cleaner Bulk (Order By The Foot Feet Required) 0 0 Clamp, Hose 0 Hose, Air Reducing 0 0 0 Clamp, Hose
Engine Gauges Generator Sets With -Wire Control H 0 00 Nipple, Pipe (/ X ) 0 0 Tee, Pipe 0 000 Bushing, Reducer (/ x /) 0 Gauge, Oil Pressure 0 Gauge, Water Temperature
Fuel System Natural Gas 0 C00 0 0 Bracket, Mounting Carburetor 0 Carburetor 0 0 Stud (M x. x ) 0 0 Nut, Lock Flange (M x.) 0 000 Nipple, Pipe (/ NPT x.0) 0 00 Bushing, Reducer (/ NPT) 0 0 Elbow, Pipe (0 ) (/) 0 00 Nipple, Pipe (/ NPT x.0) 0 00 Nipple, Close (/ x /) 0 0 Regulator, Natural Gas 0 0 Nipple, Pipe (/ NPT x.0) 0 0 0 Valve, Solenoid Clamp, Muffler 00 Washer, Flat (M) 00 0 Screw, Hex Head (M x ) Clamp, J 0 Gasket, Carburetor 00 Plug, Hole
Fuel System Propane Vapor 0 C0 0 0 Bracket, Mounting Carburetor 0 Carburetor 0 0 Stud (M x. x ) 0 0 Nut, Lock Flange (M x.) 0 000 Nipple, Pipe (/ NPT x.0) 0 00 Bushing, Reducer (/ NPT) 0 0 Elbow, Pipe (0 ) (/) 0 00 Nipple, Pipe (/ NPT x.0) 0 00 Nipple, Close (/ x /) 0 0 0 Nipple, Pipe (/ NPT x.0) 0 0 0 Valve, Solenoid 0 Regulator, LPG Vapor Clamp, Muffler 00 Washer, Flat (M) 00 0 Screw, Hex Head (M x ) 0 Gasket, Carburetor 00 Plug, Hole Clamp, J
Fuel System Propane Liquid 0 0 0 C0 0 0 Bracket, Mounting Carburetor 0 Carburetor 0 0 Stud (M x. x ) 0 0 Nut, Lock Flange (M x.) 0 000 Nipple, Pipe (/ x ) 0 000 Elbow, Pipe 0 (/) 0 00 Nipple, Pipe (/ x.) 0 00 Nipple, Pipe (/ x ) 00 Washer, Flat (M) 0 00 0 Screw, Hex Head (M x ) 0 Regulator 0 0 0 Valve, Solenoid 0 0 Connector, Hose (0 ) 0 0 Clamp, Hose 0 0 Hose, Flex Bulk (Order by the Foot Feet Required) (/ ) 0 00 Nipple, Short (/ x.) 0 0 Cap, Pipe (/) 0 Washer, Flat (/) Bracket, Support 0 Harness, LPG 0 0 Hose, Flex Bulk (Order by the Foot Feet Required) (/ ) 0 Gasket, Carburetor Clamp, J 0 00 Nipple, Pipe (/ x -/)
Fuel System Natural Gas With Low Fuel Pressure Warning Switch Begin Spec B 0 0 H,C00 0 0 Bracket, Governor 0 000 Nipple, Pipe (/ x.00) 0 00 Bushing, Reducer (/ x /) 0 0 Elbow, Pipe 0 00 Nipple, Pipe (/ x.00) 0 00 Nipple, Close (/) 0 Regulator, Natural Gas 0 0 Nipple, Pipe (/ x.00) 0 0 0 Valve, Solenoid (V) 0 0 Tee, Reducing 0 000 Bushing (/ x /) 0 0 Switch, Pressure (V) 0 00 Elbow, Street 0 (/) 00 Plug, Hole 0 0 Stud (M x.) 0 0 Nut, Lock Flanged 00 0 Screw, Hex Head (M x. x ) Clamp, Muffler (. ) 00 Washer, Flat (M) 0 0 Carburetor 0 Gasket, Carburetor 0 Harness, Fuel Alarm
Fuel System Propane Vapor With Low Fuel Pressure Warning Switch Begin Spec B 0 0 H,C0 0 0 Bracket, Governor 0 000 Nipple, Pipe (/ x.00) 0 00 Bushing, Reducer (/ x /) 0 0 Elbow, Pipe 0 00 Nipple, Pipe (/ x.00) 0 00 Nipple, Close (/) 0 Regulator, LPG Vapor 0 0 Nipple, Pipe (/ x.00) 0 0 0 Valve, Solenoid (V) 0 0 Tee, Reducing 0 000 Bushing (/ x /) 0 0 Switch, Pressure (V) 0 00 Elbow, Street 0 (/) 0 00 Plug, Hole 0 0 Stud (M x.) 0 0 Nut, Lock Flanged 00 0 Screw, Hex Head (M x. x ) Clamp, Muffler (. ) 00 Washer, Flat (M) 0 0 Carburetor 0 Gasket, Carburetor 0 Harness, Fuel Alarm
Fuel System Natural Gas / Propane Vapor With Low Pressure Switch and Automatic Changeover 0 0 0 0 C0 0 0 Bracket, Mounting Carburetor 0 Carburetor 0 0 Stud (M x. x ) 0 0 Nut, Lock Flange (M x.) 0 000 Nipple, Pipe (/ x ) 0 0 Elbow, Pipe (0 ) (/) 0 00 Nipple, Close (/ x /) 0 Regulator, Natural Gas 0 0 Nipple, Pipe (/ NPT x.0) 0 0 0 0 Valve, Solenoid 0 Regulator, LPG Vapor 0 0 Tee, Reducing 0 00 Union, Ground Joint (/ NPT) 0 00 Nipple, Pipe (/ NPT x.) 0 0 Valve (/) 0 0 Nipple, Pipe (/ NPT x.0) 0 Tee, Reducing 0 00 Nipple, Pipe (/ NPT x.0) Bracket, Support 0 Clamp, Muffler 00 Washer, Flat (M) 00 0 Screw, Hex Head, (M x. x ) Harness, Dual Fuel Includes Relay Spec A, B Begin Spec C 0 0 Relay ( Volt) (K) Clamp, J 0 Gasket, Carburetor 00 Plug, Hole 0 0 0 Switch, Low Pressure 0 000 Bushing, Reducer (/ x /) 0
Fuel System Natural Gas / Propane Liquid With Low Pressure Switch and Automatic Changeover 0 0 0 C00 0 0 Bracket, Mounting Carburetor 0 Carburetor 0 0 Stud (M x. x ) 0 0 Nut, Lock Flange (M x.) 0 000 Nipple, Pipe (/ NPT x.0) 0 00 Bushing, Reducer (/ NPT) 0 0 Elbow, Pipe (0 ) (/ ) 0 00 Nipple, Close (/ NPT x /) 0 Regulator, Natural Gas 0 0 0 Nipple, Pipe (/ NPT x.0) 0 0 0 Valve, Solenoid 0 0 Tee, Reducing 0 00 Union, Ground Joint (/ NPT) 0 00 Nipple, Pipe (/ NPT x.) 0 0 Valve (/) 0 Tee, Reducing 0 00 Nipple, Pipe (/ NPT x.) 0 00 Nipple, Pipe (/ NPT x.0) Bracket, Support 0 Clamp, Muffler 00 Washer, Flat (M) 00 0 Screw, Hex Head (M x. x ) 0 Regulator 0 0 0 Valve, Solenoid 0 0 Connector, Hose (0 ) 0 0 Clamp, Hose 0 0 Hose, Flex Bulk (Order by the Foot Feet Required) (/ ) 0 0 Cap, Pipe (/ NPT) 0 Washer, Flat (/) 0 Bracket, Support Harness, Dual Fuel Includes Relay Spec A, B Begin Spec C 0 0 Relay ( Volt) (K) Harness, LPG 0 0 Hose, Flex Bulk (Order by the Foot Feet Required) (/ ) 0 Gasket, Carburetor 00 Plug, Hole Clamp, J 0 0 0 Switch, Low Pressure 0 000 Bushing, Reducer (/ x /)
Muffler Housed Sets A0 0 00 Elbow, 0 ( / ) 0 Tube, Exhaust 0 0 Elbow, Street 0 ( / ) 0 00 Bracket, Air Cleaner 00 0 Muffler, Critical 00 Screw, Lock (M x. x 0) 0 0 Nut, Lock (M x.) Shield, Heat Muffler Spacer, Muffler
Low Coolant Level Switch 0 H,H 0 0 Tank, Coolant 0 Hanger, Tank 0 Bracket, Coolant Tank 0 Switch, Low Coolant Level (S) 00 0 Screw, Hex Head (M x. x 0) 0 Screw, Self-Locking Flange Head (M x x 0) A/R Tie, Cable Harness, Pigtail (Includes Parts Marked *) *Housing, Connector ( Pin) 0 0 *Socket, Contact 0 *Seal, Cable 0 Cap, Tank * Parts Included in Pigtail Harness
Coolant Heater 0 0 Bracket, Heater Heater, Engine Coolant 0 0 0 Volt 0 0 0/0 Volt 0 0 Hose, Engine Coolant Bulk (Order by the Foot Foot Required) 0 00 Tee 0 0 Clamp, Hose 00 0 Screw, Hex Head (M x x ) 00 Screw, Self-Locking Hex Washer Head (M0 x. x 0) 0 0 Hose, Engine Coolant Bulk (Order by the Foot Foot Required) 0 0 Adapter, Hose 0 0 0 Hose, Engine Coolant Bulk (Order by the Foot Foot Required)
Radiator Drain E0 0 0 Clamp, Hose 0 Hose, Radiator Drain ( )
Duct Adapter F0 0 Adapter, Duct Side 0 Adapter, Duct Top and Bottom 00 0 Screw, Hex Head SEMS (M x. x 0) 0 0 Rivet, Pop
Remote Radiator E0 0 Guard, Alternator Belt 0 Screw, Lock (M x x ) Guard, Belt 0 0 Hose, Radiator 0 Clamp, Hose 00 0 Screw, Cap Hex Head (M x. x ) 0 00 Washer, Lock (M)
Radiator Spec A 0 0 E0,E0,F00 0 Radiator 0 Bolt, Carriage (/ x ) 0 Mount, Radiator 0 Shroud, Fan 0 Guard, Fan 0 Brace, Radiator (LH) 0 Brace, Radiator (RH) 0 Fan, Engine 0 0 0 Spacer, Fan 0 00 0 Screw, Hex Head Cap (M x. x 0) 0 0 Hose, Radiator Inlet (Top) 0 0 Clamp, Hose 0 0 Hose, Radiator Outlet (Bottom) 0 Guard, Radiator (Unhoused Sets only) 0 0 Cap, Radiator PSI Screw, Hex Head Thread Cutting (#0 x /) 0 Housed Sets 0 Unhoused Sets 0 Guard, Alternator Belt 00 0 Screw, Hex Head (M x. x 0) 0 0 Nut, Self-Locking (/ ) 0 0 Washer, Flat (/) 0 0 Nut, Hex (/ ) 0 0 Hose, Engine Coolant Bulk (Order by the Foot Feet Required) 0 0 Clamp, Hose Clamp, J 0 Screw, Flange (M x x ) 0 00 Washer, Lock (M) 0 0 Plug, / Hex Head Pipe
Radiator Begin Spec B 0 0 0 (Unhoused) (Housed) E0,F,F 0 Radiator 0 Bolt, Carriage (/ x ) 0 Mount, Radiator 0 00 0 Shroud, Fan 0 0 Guard, Fan (LH) 0 Brace, Radiator (LH) 0 Brace, Radiator (RH) 0 Fan, Engine 0 0 0 Spacer, Fan 0 00 0 Screw, Cap Hex Head (M x. x 0) 0 0 Hose, Radiator Inlet (Top) 0 0 Clamp, Hose 0 0 Hose, Radiator Outlet (Bottom) 0 Guard, Radiator (Unhoused Sets) 0 0 Cap, Radiator PSI Screw, Hex Head (M x. x 0) 0 Housed Sets 0 Unhoused Sets 0 Guard, Alternator Belt Screw, Hex Head (M x. x 0) 00 0 Housed Sets 00 0 Unhoused Sets 0 0 Nut, Self-Locking (/ ) 0 0 Washer, Flat (/) 0 0 Nut, Hex (/ ) 0 0 Hose, Engine Coolant 0 0 Clamp, Hose Clamp, J 0 Screw, Flange (M x x ) 0 0 Rivet, Pop (/) 0 00 Washer, Lock (M) 0 0 Plug, / Hex Head Pipe 0 0 Guard, Fan (RH) 0 0 0 Brace, Radiator 0 0 Brace, Radiator 0 0 Clamp 00 0 Screw, Hex Head (M x. x 0)
Skid 0 0 0 F,C00,C0,C0,C0,C00 Base, Skid 0 Spec A D 0 0 0 Begin Spec E 0 0 Cushion, Vibration Isolation (Engine End) ( / x /) 0 0 Cushion, Vibration Isolation (Generator End) ( / x /) 0 00 Bushing, Spacer 0 Bracket, Front Engine Mounting 0 0 Spacer 0 0 Cushion, Mounting Rubber ( / x /) 00 Washer, Flat (/) 0 00 Washer, Lock (/) 0 00 00 Screw, Cap Hex Head (/ x.) 0 Spacer, Engine Support 0 Washer, Flat (/) 0 Washer, Flat (/) 00 0 Screw, Cap Hex Head (M x. x 0) 00 0 Screw, Cap Hex Head (M0 x. x.) 00 0 Screw, Cap Hex Head (M0 x. x 0) 000 Washer, Lock EIT (/) 0 0 Nut, Lock (/ ) 0 Battery, Hold Down Spec A D 0 00 00 Screw, Cap Hex Head (M x x 0) Spec A D 0 0 Washer, Lock (M) Spec A D 0
Battery Cover Begin Spec E Cover, Battery 0 Hold Down, Battery 00 0 Screw, Hex Head (M x x 0)
This Page Intentionally Left Blank.
Housing Standard Weather Protective 0 0 0 F00,F 0 0 Panel, Front Housing 0 Post, Corner 0 Roof, Housing 0 0 Nut, Weld Stud 0 Catch, Housing Door 000 Screw, Lock Head (/ 0 x /) 0 Door, Housing (Side) 0 Door, Housing (Rear) 0 0 Latch, Door 0 0 0 Bracket, Door 00 Screw, Machine Round Head (# x ) 0 0 Nut (# ) 0 Bumper, Housing 0 Bracket, Housing 0 0 Bracket, Housing 00 0 Screw, Hex Head (M x. x 0) 00 0 Screw, Hex Head (M x. x ) 0 0 Rivet, Pop 0 0 Plug, Hole 0 0 Clip, Door 00 Rivet, Drive 000 Washer, Flat (/) 0 0 Insulation, Foam 0 Seal, Weather (. ) 0 0 Panel, Housing 0 00 Bushing, Reducer ( / x /) 0 00 Coupling, Pipe ( /) 0 Shield, Rain 0 0 0 Label, Logo 0 0 00 Label, Prototype Tested 0 Label, Coolant Fill 0 0 Label, Warning 0 Label, Warning
Housing Quiet Site Second Stage Begin Spec B 0 0 0 0 0 F
Housing Quiet Site Second Stage Begin Spec B 0 0 Panel, Front Housing 0 Post, Corner 0 0 Panel, Housing 0 Panel, Insulation 0 0 0 Support, Insulation 0 Panel, Insulation 0 Roof, Housing 0 0 Nut, Weld 0 Catch, Housing Door 0 000 Screw, Self-Locking Hex Washer Head (/ 0 x.0) 0 Door, Housing 0 Door, Housing 0 0 Latch, Door 0 Bumper, Housing 0 Bracket, Housing 0 0 Bracket, Housing 00 0 Screw, Hex Head (M x. x 0) 00 0 Screw, Hex Head (M x 0. x ) 0 0 Plug, Hole 0 0 Clip, Door 00 Rivet, Drive (/) 000 Washer, Flat (/) 0 0 Rivet, Pop 0 0 0 Label, Logo 0 00 Label, Prototype 0 Label, Coolant Fill 0 0 Label, Warning 0 Label, Warning 0 Seal, Weather 0 0 Panel, Insulation 0 Panel, Insulation 0 Shield, Rain 0 00 Coupling, Pipe 0 00 Bushing, Reducer (-/ x -/) 0 0 Duct, Air Outlet 0 0 Duct, Air Outlet 0 Panel, Insulation 0 0 Duct, Air Outlet 0 Panel, Insulation 0 0 00 0 Support, Insulation 0 Label, Caution 00 0 0 Screw, Hex Head (M x. x 0) 0 0 Brace, Radiator 0 0 Brace, Radiator 0 0 Clamp (Used with Item and Radiator Brace Not Illustrated) 0 Label
Starter CP0 Starter Complete (.kw) (B) Kit, Starter Brush Switch Clutch Armature Frame, Commutator End 0 Housing Bearing, Commutator End Bearing, Pinion End
Governor Spec A C 0 A 0 0 Governor (Includes Lever) (A) 00 Washer, Flat (/) 0 000 Washer, Split Lock (/) 00 00 Screw, Cap Hex Head (/ x.) 00 000 Screw, Cap Hex Head (/ 0 x _/) 0 0 Nut, Locking (/ 0) 0 0 Joint, Ball 0 Stud, Governor Link 0 0 Nut, W/ET (#0 ) 0 0 0 Lever, Governor 0 Pickup, Magnetic (P) Clamp, Loop (Insulated) 0 0 Spring
Governor Begin Spec D 0 0 0 0 Bracket, Governor 0 0 Governor (Includes Lever) (A) 00 Washer, Flat (/) 0 000 Washer, Split Lock (/) 00 00 Screw, Cap Hex Head (/ x.) 00 000 Screw, Cap Hex Head (/ 0 x _/) 0 0 Nut, Locking (/ 0) 0 0 Joint, Ball 0 Stud, Governor Link 0 0 0 Nut, W/ET (#0 ) 0 0 Lever, Governor 0 Pickup, Magnetic (P) Clamp, Loop (Insulated) 0 0 Spring 0 Map, Sensor Ignition 0 0 Hose, Vacuum 00 Screw, Machine Round Head (#0 x -/)
Control Housing Detector Control 0 Panel, Control Housing Panel, Control Housing Top Cover, Control Housing Sets W/Circuit Breaker Sets W/O Circuit Breaker Screw, Hex Head (M x x ) 00 0 Sets W/Circuit Breaker 00 0 Sets W/O Circuit Breaker Bracket, Control Saddle 0 0 Spec A C 0 0 Begin Spec D 000 Washer, Lock W/IT (/) 0 Screw, Thread Cutting (/ x /) 00 Screw, Locking (/ x /) 0 00 0 Edging Bulk (Order By The Foot Foot Required) 0 Block, Terminal 00 0 Screw, Hex Head (M x 0. x ) 000 Washer, Lock W/EIT (/) Used With Engine Harness (Not Illustrated)
Overspeed Switch Detector Control 0 H0,H 000 Screw, Lock (/ 0 x / ) 0 0 Switch, Overspeed 0 Screw, Cap Hex Head ( x / ) 00 00 Screw, Cap Hex Head (/ x / ) 00 Washer, Flat (/) 000 Washer, Lock EIT (/ ) 0 Bracket, Overspeed Switch 00 Washer, Lock ET (/ ) 000 Nut, Hex (/ 0) 0 0 00 Nut, Insulation (/ 0) 0 0 Point, Overspeed 0
Electronic Overspeed -Wire Control 0 H Bracket, Overspeed 00 Board, Printed Circuit Overspeed 00 Washer, Flat (/) 0 Washer, Flat (/) 0 Rotor, Ignition 0 000 Washer, Lock Spring (/) 00 00 Screw, Cap Hex Head (/ x.) 0 Screw, Pan Head Slotted (M x ) 0 00 Washer, Lock Spring (M) 0 0 00 Nut, Hex (M) 00 0 Screw, Hex Head (/ 0 x /)
Generator Spec A D 0 0 0 B,B,B,B,B0,B,B0
Generator Spec A D Stator, Generator 0 0 Lead 0 0 Lead 0 0 Lead 0 0 Lead, Full Output on Single Phase Rotor Assembly, Generator (Includes parts marked *) 0 0 mm Stack Length 0 0 mm Stack Length 0 * Rotor Assembly, Exciter (Includes Parts Marked #) 00 *# Rectifier Assembly Positive 000 *# Rectifier Assembly Negative 000 *# Washer, Lock ET (#0) 000 *# Screw, Round Head Machined (#0 UNF x /) 000 0 *# Washer, Flat (#0) 0 0 *# Nut, Hex W/ET (#0 ) 0 A/R * Disk, Rotor Drive 0 0 * Fan, Generator 0 0 * Bearing, Ball 0 * Washer, Flat (#0) 0 0 0 * Nut, Hex W/ET (#0) 0 * Washer, Flat (. Hardened) 00 0 * Screw, Cap Hex Head (. x.) (Special) 0 0 Bell, End 0 00 Stator, Exciter 0 00 Seal, O-Ring 0 0 Screw, Hex Head Thread Cutting W/ET (#0 x /) Board, Connection Terminal, Tab 000 Rivet 0 00 Screw, Cap Socket Head (/ 0 x.) 0 000 Washer, Lock (/) Stud 0 0 mm Stack Length 0 000 mm Stack Length 0 Baffle, Air 0 00 Bolt, Place (. UNC x.) 000 Screw, Lock (. 0 UNC x.0) 0 0 0 0 Washer, Lock (.) 00 0 Nut, Hex (. ) * Parts Included in Generator Rotor Assembly # Parts Included in Exciter Rotor Assembly
Generator Begin Spec E 0 0 0 B,B,B,B,B0,B,B0
Generator Begin Spec E Stator, Generator 0 0 Lead 0 0 Lead 0 0 Lead 0 0 Lead, Full Output on Single Phase Rotor Assembly, Generator (Includes parts marked *) 0 0 0 mm Stack Length 0 0 0 mm Stack Length 0 0 * Rotor Assembly, Exciter (Includes Parts Marked #) 00 *# Rectifier Assembly Positive 000 *# Rectifier Assembly Negative 000 *# Washer, Lock ET (#0) 000 *# Screw, Round Head Machined (#0 UNF x /) 000 0 *# Washer, Flat (#0) 0 0 *# Nut, Hex W/ET (#0 ) 0 A/R * Disk, Rotor Drive 0 0 * Fan, Generator 0 0 * Bearing, Ball 000 * Washer, Flat (#0) 0 0 * Nut, Hex W/ET (#0) 0 * Washer, Flat (. Hardened) 00 0 * Screw, Cap Hex Head (. x.) (Special) 0 0 Bell, End 0 0 Stator, Exciter 0 00 Seal, O-Ring 0 0 Screw, Hex Head Thread Cutting W/ET (#0 x /) Board, Connection Terminal, Tab 000 Rivet 0 000 0 Screw, Cap Socket Head (/ 0 x ) 0 0 0 Washer, Lock (/) Stud 0 0 mm Stack Length 0 000 mm Stack Length 0 Baffle, Air 0 00 Bolt, Place (. UNC x.) 000 Screw, Lock (. 0 UNC x.0) 0 0 0 0 Washer, Lock (.) 00 0 Nut, Hex (. ) * Parts Included in Generator Rotor Assembly # Parts Included in Exciter Rotor Assembly
Generator Heater A 0 Heater, Generator (Includes Heater Cord) 0 Cord, Heater 00 Nut, Lock (/) Cover, End Bell 0 Sets With Generator Heater 0 Sets Without Generator Heater 0 000 Washer, Lock Split (/) 0 Screw, Round Head (/ 0 x )
Control Heater 0 A 0 Mount, Tie Cable 0 Label, Caution 00 0 Heater, Control 0 Volt 0 A/R Sleeving, Convoluted 0 Rectifier, Power Terminal, Receptacle 0 Terminal, Tab 00 A/R Tubing, Heat Shrink Splice, Window ( Gauge) 0 0 Cable, Heater Control (Includes Parts Marked *) 00 * Cable * Terminal, Ring * Terminal, Receptacle 0 * Terminal, Tab 0 Tie, Cable 00 00 Screw, Cap Hex Head (/ x /) 0 0 Nut, Hex Self Locking (/ ) 000 Washer, Lock EIT (/) * Parts Included In 0 Control Heater Cable
Detector Control  0 0 0 0 0 H,0 0 0
Detector Control 00 Box, Control 0 0 Isolator, Vibration 0 00 Washer, Lock Spring (/) 0 00 Grommet (Fits Hole) 0 0 Receptacle, Fastener 0 0 Stud, Fastener 0 0 Washer, Stud Retainer 00 Clip, Wire 0 0 Nut, Hex W/ET (#0 ) 0 00 Nut, Hex (/ 0) 00 Washer, Flat (/ ) 00 Strap, Ground 00 00 Screw, Cap Hex Head (/ x / ) 00 0 Screw, Pan Head Cross Recessed (#0 x / ) 000 Washer, Lock EIT (/ ) 000 Screw, Self Locking Hex Washer Head (#0 x / ) 0 0 0 Door, Control AC Harness, Wiring AC Control Door (Includes Terminal Block) ( Wire, ) (TB, GND to GND, M,,, S, DS,) 00 Block, Terminal ( Place) (TB) 0 0 Light, Indicator Upper/Lower Scale (DS,) Voltmeter, AC (M) 0 0 00/00 0 0 00 0 Ammeter AC (M) 0 Meter, Frequency (M) 000 Washer, Lock ET (#0) 0 0 Switch, Rotary Voltmeter/Ammeter (Includes Handle) (S) Strip, Marker 00 0 Screw, Cross Recessed Thread Forming (# x / ) 0 Capacitor Voltmeter (. Mfd., 00 WVDC) (C) 0 0 Nut, Hex W/ET (# ) 0 0 0 Screw, Machine Round Head (M x mm) Harness, Wiring Terminal Block ( Wire, ) (Includes Connector Plug and Sockets) (P to TB) 0 Plug, Connector (P) Socket, Contact 00 00 Screw, Cap Hex Head (/ x / ) 0 0 Nut, Hex (# 0) 000 0 Screw, Self Locking Hex Washer Head (#0 x / ) 0 Screw, Pan Head (Cross Recessed (# x / ) 0 0 0 Door, Control DC 0 Screw, Machine Round Head (# x / ) 0 0 0 Nut, Hex W/ET (# ) Harness, Wiring DC Control Door (Includes Connector Housing and Contact Pins) ( Wire, ) (AJ to GND, M,,,, S,, DS) 0 Housing, Connector (J) 0 Pin, Contact 00 Board Assembly, Printed Circuit Engine Monitor (Includes Fuses) (A) Fuse 00 0 Amp (Tan) (F, F) 00 0 Amp (Light Blue) (F) 00 0 0 Amp (Yellow) (F, F) 00 0 Light Assembly, Indicator (Includes Wiring Harness and Connector Housing) (A) 0 0 Light, Indicator Replacement 0 Light, Panel (DS) 000 Bulb, Panel Light Replacement 0 0 Gauge, Oil Pressure (M) 0 Gauge, Water Temperature (M) 0 Voltmeter, DC (M) 0 00 Meter, Hour (M) 0 Plug, Hole (Fits / Hole) 0 00 Switch, Rocker Lamp Test/Reset Panel Lamp (S) 0 0 Switch, Rocker Run/Stop/Remote (S) 000 Washer, Lock ET (#0) 00 0 Board, Printed Circuit Sensor Board (A) 00 Plug, Hole (Fits / Hole) (Quantity Used As Required) 0 00 Plug, Hole (Fits Hole) (Quantity Used As Required) 0 0 Handle, Rotary Switch 0 0 Lens, Replacement Check Engine (DS or DS0)
-Wire Control 0 0 0 0 H 0
-Wire Control Box, Control Panel, Control Front Cover, Control Plate, Control Sets Without Circuit Breaker 0 Holder, Fuse 0 Fuse (0 Amp) 0 Relay, Timer 0 00 Meter, Hour Block, Terminal 0 0 0 Regulator, Voltage (VR) 0 0 Relay (0 Amp) (K) 0 0 Switch, Rocker 00 0 Screw, Hex Head (M x 0. x ) 0 Bushing, Nylon 00 0 0 Screw, Hex Head (M x x ) 0 0 0 Nut, Lock Nylon (M) 0 Plug, Hole 0 0 Screw, Slotted Flat Head Thread Forming (M x 0. x 0) Harness, Control 0 Spec A (Includes Parts Marked *) Begin Spec B (Includes Parts Marked #) 0 *# Block, Terminal (TB) 000 *# Rectifier ( Amp) (CR) (Mounted on K Relay) 0 0 *# Relay (K K) Breaker, Circuit 0 Pin 0 0 Pin 0 0 Nut, Hex (M) 000 Washer, Lock EIT (/ ) 0 0 Isolator, Vibration Bracket, Control Saddle 0 0 Spec A C 0 0 Begin Spec D 000 Washer, Lock EIT (/ ) 0 Screw, Cap Hex Head Thread Forming (/ x / ) 0 0 0 Nut, Locking Hex Flange Head (M) Strip, Marker Cover, Circuit Breaker 0 Used With Pole Circuit Breaker Used With Pole Circuit Breaker Spec A 0 Used With Pole Circuit Breaker 0V Begin Spec B Used With Pole Circuit Breaker 00V Begin Spec B Bracket, Mounting Circuit Breaker Used With Pole Circuit Breaker Spec A 0 0V Begin Spec B 00V Begin Spec B 0 0 0 Nut, Lock (M) Used With Pole Circuit Breaker 00 0 Screw, Hex Head (M x 0. x 0) Used With Pole Circuit Breaker Screw, Hex Head (M x x ) 00 0 Used With Pole Circuit Breaker 00 0 Used With Pole Circuit Breaker Lead 0 Used With Pole Circuit Breaker 0 Used With 0 00 Amp Circuit Breaker 0 Used With 0 Amp Circuit Breaker * Parts Included in 0 Control Harness # Parts Included in Control Harness
Wiring Harness Generator Sets With Detector Control Spec A C 0 0 0
Wiring Harness Generator Sets With Detector Control Spec A C 0 Harness, Wiring Engine to Control (Includes Parts Marked +) Spec A, B Harness, Wiring Engine to Control (Includes Parts Marked *) Spec C 0 *+ Housing, Connector Place (J) 0 *+ Housing, Connector Place (J) *+ Housing, Connector Place (J) *+ Relay (K) 0 0 *+ Spec A, B 0 0 *+ Spec C 00 *+ Socket, Contact (Used in J,J) 0 00 *+ Resistor (0 Ohms) (Located in Harness Sleeving at P and P End) 000 *+ Rectifier, Silicon ( Amp) 0 + Resistor ( Ohms) (Used on TB) *+ Socket, Contact (Used on E) 00 0 *+ Bracket, Terminal Mounting 00 *+ Block, Terminal Place (T) 0 *+ Jumper (T) 0 *+ Screw, Machine Round Head Cross Recessed W/IT ( x.0) *+ Plug, Connector (Used in E) *+ Wedge, Plug (Used in E) *+ Plug (Used in E) 0 *+ Pin, Contact (Used in J) 0 00 + Connector Place (P) 0 + Wedge, Connector (Used in P) *+ Connector Place (P) *+ Socket, Contact (Used in P) *+ Connector Place (P) *+ Socket, Contact (Used in P) 00 + Socket, Contact (Used in P) * Housing, Connector Pin (S) * Seal 0 0 * Seal, Cable (S) (P) 0 0 * Connector 0 Pin (P) 0 * Socket, Contact (Used in P) * Housing, Lock (P) Harness, Wiring AC Auxiliary (Includes Parts Marked #) 0 # Housing, Plug (J) # Pin, Contact (Used in J) * Parts Included in Engine to Control Wiring Harness + Parts Included in 0 Engine to Control Wiring Harness # Parts Included in AC Auxiliary Wiring Harness
Wiring Harness Generator Sets With Detector Control Begin Spec D 0 0 0
Wiring Harness Generator Sets With Detector Control Begin Spec D 0 Harness, Wiring Engine to Control (Includes Parts Marked *) 0 * Housing, Connector Place (J) 0 * Housing, Connector Place (J) * Housing, Connector Place (J) 0 0 * Relay (K) 00 * Socket, Contact 0 0 * Relay, Power (K) 0 0 * Bracket, Relay 0 00 * Resistor (0 Ohms) (Located in Harness Sleeving at P End) 0 * Housing, Connector Pin (S) 00 * Screw, Machine Round Head (# x.0) * Plug, Cavity (S) (P) 0 0 * Nut, Hex W/ET (# ) 0 0 * Seal, Cable (S) (P) * Socket, Contact 00 0 * Bracket, Terminal Mounting 00 * Block, Terminal Place (T) 0 * Jumper (T) 0 * Screw, Machine Pan Head Cross Recessed W/ET ( x.0) 0 0 * Cover, Terminal Block (Includes Spring Clips) * Plug, Connector (E) * Wedge, Plug * Plug ( Pin) 0 * Socket, Contact (S) 0 * Pin, Contact 0 * Connector 0 Pin (P) * Housing, Lock (P) * Connector Place (P) * Socket, Contact (P) 0 * Connector Place (P) * Socket, Contact (P) 0 * Socket, Contact (P) 0 0 * Boot Harness, Wiring AC Auxiliary (Includes Parts Marked #) 0 # Housing, Plug (J) # Pin, Contact (J) * Parts Included in 0 Engine to Control Wiring Harness # Parts Included in AC Auxiliary Wiring Harness
Wiring Harness Generator Sets With -Wire Control Spec A C 0 0 0
Wiring Harness Generator Sets With -Wire Control Spec A C Harness, Wiring Engine to Control (Includes Parts Marked *) Spec A Harness, Wiring Engine to Control (Includes Parts Marked ^) Spec B Harness, Wiring Engine to Control (Includes Parts Marked +) Spec C 00 ^* Connector Place (P) 0 ^* Wedge, Connector (Used in P) 00 ^* Socket, Contact (Used in P) +^* Socket, Contact (Used in P) +^* Connector Place (P) +^* Socket, Contact (Used in P) 0 +^* Connector One Place (P) ^* Socket, Contact (Used in P) ^* Plug, Connector Place (P) ^* Wedge, Plug (Used in P) 0 00 +^* Resistor (0 Ohms) (Located in Harness Sleeving at P and P End) 000 +^ Rectifier, Silicon ( Amp) (CR) 0 + Connector 0 Pin (P) 0 + Socket, Contact (Used in P) 0 + Seal (P) + Seal, Plug (P) 0 + Housing, Lock (P) * Parts Included in Engine to Control Wiring Harness ^ Parts Included in Engine to Control Wiring Harness + Parts Included in Engine to Control Wiring Harness
Wiring Harness Generator Sets With -Wire Control Begin Spec D 0 0 Harness, Wiring Engine to Control (Includes the Following Parts) 0 Connector 0 Pin (P) Housing, Lock (P) 0 Socket, Contact (P) Socket, Contact (P) Connector Place (P) 0 0 Boot Socket, Contact (P) Connector One Place (P) 0 0 Seal (P) Seal, Plug (P) 0 0 Relay (K) 0 00 Resistor (0 Ohms) 000 Diode (CR)
Dry Contact -Wire Control Begin Spec B 0 H 0 0 Panel, Relay 0 0 Relay (K, K) 00 0 Screw, Hex Head (M x 0. x ) 000 0 Screw, Hex Head (#0 x / ) Harness, Wiring Control Harness, Wiring Dry Contact (Includes Parts Marked #) # Housing, Connector ( Pin) A/R # Plug, Cavity 0 A/R # Socket, Contact (Used in S) 0 0 A/R # Seal, Cable 0 0 Standoff, Hex (#0 ) 0 0 Nut, Hex W/ET (#0 ) # Parts Included in Wiring Harness
Voltage Regulator Detector Control B0 0 0 Potentiometer (R) 0 0 Board, Printed Circuit Voltage Regulator (Model SX0) (VR) 0 Resistor (TB) 00 0 Screw, Cross Recessed (#0 x /) 0 Jumper 0 0 Breaker, Circuit (CB) 0
Vacuum Switch C0 0 00 Elbow, Street 0 000 Bushing, Reducer (/ NPT x / NPT) 0 00 Nipple, Pipe (/ NPT x.) 0 Switch, Vacuum A/R Tie, Cable Harness, Vacuum Switch
Control Door Cover Generator Sets With Detector Control Begin Spec E 00 0 A/R Cover, Control Door Meters 0 0 A/R Nut, Hex W/ET (#0 )
Circuit Breaker Mounting Bracket Detector Control KB,,KM0,0,0,0,0,0,0,0, Bracket, Mounting Circuit Breaker Used With Pole Circuit Breaker Used With Pole Circuit Breaker Spec A 0 0 Used With Pole Circuit Breaker 0V Begin Spec B Used With Pole Circuit Breaker 00V Begin Spec B 0 0 Rivet, Pop Cover, Circuit Breaker 0 Used With Pole Circuit Breaker 0 Used With Pole Circuit Breaker Spec A 0 Used With Pole Circuit Breaker 0V Begin Spec B 0 Used With Pole Circuit Breaker 00V Begin Spec B 00 0 Screw, Hex Head (M x 0. x 0) Used With Pole Circuit Breaker 0 0 0 Nut, Lock (M) Used With Pole Circuit Breaker 00 0 Screw, Hex Head (M x x ) Lead 0 Used With Pole Circuit Breakers 0 Used With 0 00 Amp Circuit Breakers 0 Used With 0 Amp Circuit Breakers 0 00 0 Edging Bulk (Order By The Foot Foot Required) Used With Pole Circuit Breakers
Circuit Breaker Spec A KM0,0,0,0,0,0,0,0,,KB,KB,K,KL Breaker, Circuit Pole (UL) 0 00 0 0 Amp 0 00 0 00 Amp Pole (UL & IEC) 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * Amp 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * 00 Amp 0 0 Package, Hardware Circuit Breaker Mounting (Includes Screws, Nuts and Lock Washers) Accessories, Circuit Breaker: The following are used on 0 XX Circuit Breakers 0 0 Contact, Auxiliary Switch 0 0 Trip, Shunt (V) * Includes Mounting Hardware
Circuit Breaker Begin Spec B KM,KM,KM,KM,KM,KM,KM,KM,K,KL,KB,KB Breaker, Circuit Pole (UL) 0 00 0 0 Amp 0 00 0 00 Amp Pole (UL & IEC) (0V) 0 00 0 * 0 Amp 0 00 0 * 0 Amp 0 00 0 * 0 Amp 0 00 0 * 0 Amp 0 00 0 * 0 Amp 0 00 0 * 0 Amp 0 00 0 * 0 Amp 0 00 0 * 000 Amp Pole (UL & IEC) (00V) 0 * 0 Amp 0 0 * 0 Amp 0 * 0 Amp 0 * 0 Amp 0 * 0 Amp 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * 0 Amp 0 0 * 00 Amp 0 0 Package, Hardware Circuit Breaker Mounting (Includes Screws, Nuts and Lock Washers) Accessories, Circuit Breaker: The following are used on 0 XX Circuit Breakers 0 0 Switch Used as Auxiliary Contact or Trip Alarm 0 0 Trip, Shunt (V) * Includes Mounting Hardware
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 00,, 0 0,, 0,, 0,, 0, 0, 0, 0 0 0,, 0 0, 0 0 0, 0, 0, 0 0, 0,, 0,, 0,, 0 0, 0, 0, 0 0,, 0 0 0,, 0,, 0,, 0,, 0, 0, 0, 0, 0, 0 0, 0 0, 0 00 0, 0 0,, 0 0,, 0 00, 0, 0,, 0 0, 0 0, 0 0, 0,,,,,, 0, 0,,, 0, 0,,, 0 0,, 0, 0,,,,,, 0,, 0,,, 0 0, 0 0 0, 0 0 0,, 0, 0 0 0,, 0 0,, 0,, 0 0,, 0,, 0 0,,,,,, 0,, 00 0, 0,,,,,, 0,,,,,, 0, 0, 0, 0,, 00,, 00,, 0, 0 0, 0 0,,,,,,,,,,,,, 00,,,,,,,,,, 0, 0, 0, 0, 0, 0, 0, 0, 0, 0, 0, 0, 0 0, 0 0, 0 0,, 0 0 0, 0 0,, 0 0,, 0 00, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0, 0, 0, 0,,,,,, 0, 0,, 0, 0, 00, 00, 00 0, 00 0, 0 0 0, 0 0 0, 0, 0, 0, 0, 0, 0 00,, 0 0, 0 0 0,, 0 0 0 0,, 0 0 0,,,,, 0, 0 0, 0 0, 0,,,,,, 0, 0 0, 0 0, 0 00, 0 0,, 0 0, 0 0, 0 0, 0 0, 0 0,, 0 0 0, 0, 00 0,, 00, 0 0,,,,, 0,,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page, 0 0,,,, 0 0,, 0 0,, 0, 0, 0, 0, 0,,,,, 0,,,,,, 0 0,,,, 0, 0, 0 0, 0 0,, 0 0, 0 0 0, 0, 0 0, 0 0, 0 0, 0 0, 0, 0, 0, 0 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 0, 0 00 0,, 0 00 0,, 0 00 0, 0 00 0, 0 00 0, 0 00 0, 0 00 0, 0 00 0, 0 00 0, 0 00 0, 0, 00 0, 00 0, 00 0, 0, 000, 00 0, 0, 0, 0 0, 0 0, 00,, 0,,, 0,, 0,, 0,,,,,,,,,, 0,, 0,,,, 0,,,, 0,,,,,, 0,,, 0,,,,,,,,,,,,,,,,, 00, 00, 00,, 00, 0, 0,,,,,,,,,, 0, 0, 0, 0,,,,, 0,,,,,,,,, 0, 0, 0, 00, 0, 00, 000,,,,,,,,, 0, 0,,,, 0,,,, 0,,,,,, 0,, 0, 0, 0 00,,, 0, 0, 0, 000,,,, 0, 00,, 000,, 0 0, 0 0 0, 0 0 0, 0 0 00, 0 0 0,, 00 0, 0 0, 0 0,,, 0 0, 0 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0, 0, 0 00, 00, 0, 0 0, 0 0, 0 0 0 0, 0 0,, 0,, 0,, 0 0,, 0 0,, 0,, 0,, 0,, 0,, 0,, 0,, 0 0,, 0, 0, 0, 0, 0 00 0, 0 0 0, 0 0,, 0 0, 0 0, 0 0, 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0,, 0, 0, 0 0, 0 0,, 0, 0, 0, 0, 0 0,, 0 0, 0 00, 0 0,, 0 00, 0 0,, 0 0,,, 0 0, 0 0,,,, 0 0,, 0 0, 0 0, 0 0, 0 0,, 0, 0, 0 0,, 0 0 0, 0 0,, 0 0,, 0, 0 0 0, 0 0, 0, 0 00, 0 00, 0 0, 0, 0 0, 0 000,,,,,, 0, 0 000,,,,, 0,, 0 00, 0 00,,,,, 0 00,, 0 00,, 0 000, 0 00, 0 00,, 0 00, 0 00, 0 00, 0, 0 00,,,, 0 00, 0 00,, 0 00,,,,, 0, 0 00, 0 00, 0 0,,,,, 0, 0 00, 0, 0 0,, 0 0, 0, 0 0, 0 00,, 0, 0 0, 0 0 0, 0 0, 0 0,,,,, 0, 0 0, 0,,, 0, 0 00, 0 00 0,, 0, 0 00,, 0 0,, 00,,,,, 0, 0, 0, 0 0,, 0, 00, 00, 00, 0 0,, 0 000,, 0 0, 0 0,,,,,, 0, 00, 00, 000,, 000,, 00, 0 00,,, 00, 0, 0, 0 0, 0,, 0, 0 0, 0, 0,, 0,, 00,,,,,, 0, 0, 00 000,, 00 00,, 00 00, 00 00, 0, 00 00, 0 00 0,, 00 00,, 00 00, 0 00 0, 00 0, 00 00, 0 00 0, 00 0, 0 00 0,, 00 0,, 0 00 0, 00 0, 00 0, 00 0, 0 00 0,, 0 00, 0 000 0, 0 00, 0 00,,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 00, 000, 0 0 0, 0 0 0, 00, 0, 000,, 00, 0,,,, 0,, 0, 0, 0,, 0 0, 0 0, 0 0, 0 0, 00 0, 00 0,, 0 0 0, 0,, 000,, 00,, 0 0,,,,, 000,,, 0,, 00, 0, 0,, 0, 00, 00, 000 0,, 00 0, 00 0,,, 00 0,, 00 0,,,, 00 0, 00 0,,,,, 00 0,,,,,, 0,, 00 0,, 0 000,,,, 0 00, 0 000, 0 00, 0 0 0 0,, 0 00, 0 00,, 0, 0 00,,, 0 00, 0 0, 0 000,,, 00, 0 000,, 000,,,, 000, 0 000,, 0 0 00, 0 00,, 0, 0 0, 000, 0 00 0,, 000, 000, 0 0,,,,,,, 0 0, 0 0,, 0 0,, 0 00, 0 0 0,,, 0, 0 0,, 0 0,, 0 0, 0 0, 0 0,,,,,,, 0,, 0 0 0,, 0 0, 00, 0,, 00, 0, LF0,
Cummins Power Generation 00 rd Ave. NE Minneapolis, MN USA Phone 000 Toll-free 00 Fax Email ask.powergen@cummins.com www.cumminspower.com Cummins, the C logo, and Our energy working for you. are trademarks of Cummins Inc. 00 Cummins Power Generation, Inc. All rights reserved.