WESTCODE An IXYS Company Date:- 18 Sept 27 Data Sheet Issue:- 2 Phase Control Thyristor Types N3533Z#14 to N3533Z#22 Old Type No.: N14CH2-2 Absolute Maximum Ratings VOLTAGE RATINGS MAXIMUM LIMITS V DRM Repetitive peak off-state voltage, (note 1) 14-22 V V DSM Non-repetitive peak off-state voltage, (note 1) 14-22 V V RRM Repetitive peak reverse voltage, (note 1) 14-22 V V RSM Non-repetitive peak reverse voltage, (note 1) 15-23 V UNITS OTHER RATINGS MAXIMUM LIMITS I T(AV) Mean on-state current. T sink=55 C, (note 2) 3533 A I T(AV) Mean on-state current. T sink=85 C, (note 2) 2377 A I T(AV) Mean on-state current. T sink=85 C, (note 3) 1398 A I T(RMS) Nominal RMS on-state current. T sink=25 C, (note 2) 752 A I T(d.c.) D.C. on-state current. T sink=25 C, (note 4) 5929 A I TSM Peak non-repetitive surge t p=1ms, V rm=.6v RRM, (note 5) 5 ka I TSM2 Peak non-repetitive surge t p=1ms, V rm 1V, (note 5) 6 ka I 2 t I 2 t capacity for fusing t p=1ms, V rm=.6v RRM, (note 5) 12.5 1 6 A 2 s I 2 t I 2 t capacity for fusing t p=1ms, V rm 1V, (note 5) 18. 1 6 A 2 s di T/dt UNITS Maximum rate of rise of on-state current (repetitive), (Note 6) 15 A/µs Maximum rate of rise of on-state current (non-repetitive), (Note 6) 3 A/µs V RGM Peak reverse gate voltage 5 V P G(AV) Mean forward gate power 5 W P GM Peak forward gate power 3 W V GD Non-trigger gate voltage, (Note 7).25 V T HS Operating temperature range -4 to +125 C T stg Storage temperature range -4 to +15 C Notes: - 1) De-rating factor of.13% per C is applicable for T j below 25 C. 2) Double side cooled, single phase; 5Hz, 18 half-sinewave. 3) Single side cooled, single phase; 5Hz, 18 half-sinewave. 4) Double side cooled. 5) Half-sinewave, 125 C T j initial. 6) V D=67% V DRM, I TM=1A, I FG=2A, t r.5µs, T case=125 C. 7) Rated V DRM. Data Sheet. Types N3533Z#14 to N3533Z#22 Page 1 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Characteristics PARAMETER MIN. TYP. MAX. TEST CONDITIONS (Note 1) UNIT S V TM Maximum peak on-state voltage - - 1.25 I TM=3A V V T Threshold voltage - -.97 V r T Slope resistance - -.95 mω dv/dt Critical rate of rise of off-state voltage 1 - - V D=8% V DRM, linear ramp, Gate O/C V/µs I DRM Peak off-state current - - 2 Rated V DRM ma I RRM Peak reverse current - - 2 Rated V RRM ma V GT Gate trigger voltage - - 3. T j=25 C, V D=1V, I T=3A V I GT Gate trigger current - - 3 ma I H Holding current - - 1 T j=25 C ma t gd Gate controlled turn-on delay time - 1. 2. t gt Turn-on time - 2. 3. V D=67%V DRM, I TM=2A, di/dt=1a/µs, I FG=2A, t r=.5µs, T j=25 C Q rr Recovered Charge - 27 - µc Q ra Recovered Charge, 5% chord - 17 23 I TM=4A, t p=1µs, di/dt=1a/µs, V r=5v µc I rm Reverse recovery current - 135 - A t rr Reverse recovery time, 5% chord - 25 - µs t q R th(j-hs) Turn-off time Thermal resistance, junction to heatsink - 25 - - 45 - I TM=4A, t p=1µs, di/dt=1a/µs, V r=5v, V dr=8%v DRM, dv dr/dt=2v/µs I TM=4A, t p=1µs, di/dt=1a/µs, V r=5v, V dr=8%v DRM, dv dr/dt=2v/µs - -.11 Double side cooled K/W - -.22 Single side cooled K/W F Mounting force 27-47 kn W t Weight - 1.7 - Outline options ZC & ZT - 1.2 - Outline options ZD & ZV µs µs kg Notes: - 1) Unless otherwise indicated T j=125 C. 2) For other clamp forces please consult factory. Notes on rupture rated packages. This product is available with a non-rupture rated package. For additional details on these products, please consult factory. Data Sheet. Types N3533Z#14 to N3533Z#22 Page 2 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Notes on Ratings and Characteristics 1. Voltage Grade Table Voltage Grade V DRM V DSM V RRM V RSM V D V R V V DC V 14 14 15 93 16 16 17 14 18 18 19 115 2 2 21 125 22 22 23 135 2. Extension of Voltage Grades This report is applicable to other and higher voltage grades when supply has been agreed by Sales/Production. 3. De-rating Factor A blocking voltage de-rating factor of.13%/ C is applicable to this device for T j below 25 C. 4. Repetitive dv/dt Standard dv/dt is 1V/µs. 5. Rate of rise of on-state current The maximum un-primed rate of rise of on-state current must not exceed 3A/µs at any time during turnon on a non-repetitive basis. For repetitive performance, the on-state rate of rise of current must not exceed 15A/µs at any time during turn-on. Note that these values of rate of rise of current apply to the total device current including that from any local snubber network. 6. Gate Drive The recommended pulse gate drive is 3V, 15Ω with a short-circuit current rise time of not more than.5µs. This gate drive must be applied when using the full di/dt capability of the device. The pulse duration may need to be configured according to the application but should be no shorter than 2µs, otherwise an increase in pulse current may be needed to supply the necessary charge to trigger. 7. Computer Modelling Parameters I AV 7.1 Device Dissipation Calculations 2 VT + VT + = 2 2 ff 4 Where V T =.97V, r T =.95mΩ, ff r T 2 r T W AV and: W AV T = R T = T th j max T K R th = Supplementary thermal impedance, see table below. ff = Form factor, see table below. Supplementary Thermal Impedance Conduction Angle 3 6 9 12 18 27 d.c. Square wave Double Side Cooled.124.122.121.119.117.113.11 Square wave Single Side Cooled.249.248.247.246.244.241.22 Sine wave Double Side Cooled.168.14.131.118.112 Sine wave Single Side Cooled.249.247.246.244.241 Form Factors Conduction Angle 3 6 9 12 18 27 d.c. Square wave 3.46 2.45 2 1.73 1.41 1.15 1 Sine wave 3.98 2.78 2.22 1.88 1.57 Data Sheet. Types N3533Z#14 to N3533Z#22 Page 3 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 7.2 Calculating V T using ABCD Coefficients The on-state characteristic I T vs. V T, on page 5 is represented in two ways; (i) the well established V T and r T tangent used for rating purposes and (ii) a set of constants A, B, C, D, forming the coefficients of the representative equation for V T in terms of I T given below: V T = A + B ln ( IT ) + C IT + D IT The constants, derived by curve fitting software, are given below for both hot and cold characteristics. The resulting values for V T agree with the true device characteristic over a current range, which is limited to that plotted. 25 C Coefficients 125 C Coefficients A 1.17281.43674226 B -.3717729.635879 C 5.397833 1-5 1.72213 1-4 D 4.65 1-3 -3.856749 1-3 7.3 D.C. Thermal Impedance Calculation p = n t = p= 1 r r p 1 e Where p = 1 to n, n is the number of terms in the series and: t =Duration of heating pulse in seconds. r t =Thermal resistance at time t. r p =Amplitude of p th term. τ p =Time Constant of r th term. t τ p D.C. Double Side Cooled Term 1 2 3 4 r p 6.72 1-3 2.78 1-3 9.476 1-4 7.12 1-4 τ p 1.226.226.586 9.6 1-3 D.C. Single Side Cooled Term 1 2 3 4 r p.1688 4.42 1-3 1.79 1-3 8.72 1-4 τ p 7.55.526.1198.128 8. Reverse recovery ratings (i) Q ra is based on 5% I rm chord as shown in Fig. 1. (ii) Q rr is based on a 15µs integration time. 15µ s (iii) i.e. Q rr = i rr. dt K Factor = t1 t2 Fig. 1 Data Sheet. Types N3533Z#14 to N3533Z#22 Page 4 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Curves Figure 1 - On-state characteristics of Limit device 1 Figure 2 - Transient Thermal Impedance.1 SSC.22K/W T j = 25 C T j = 125 C Instantaneous On-state current - I TM (A) 1 Transient thermal impedance (K/W).1.1 DSC.11K/W.1 1.5 1 1.5 2 2.5 Instantaneous On-state voltage - V TM (V).1 1E-5.1.1.1.1 1 1 1 Time (s) Figure 3 - Gate Characteristics - Trigger Limits Figure 4 - Gate Characteristics - Power Curves 8 2 7 T j =25 C 18 T j =25 C 16 6 Gate Voltage - V G (V) 5 4 3 I GT, V GT Max V G dc Gate Voltage - V G (V) 14 12 1 8 Max V G dc P G Max 3W dc 2 125 C 25 C -1 C -4 C Min V G dc 6 4 P G 5W dc 1 I GD, V GD 2.2.4.6.8 1 Gate Current - I G (A) Min V G dc 2 4 6 8 1 Gate Current - I G (A) Data Sheet. Types N3533Z#14 to N3533Z#22 Page 5 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Figure 5 Recovered Charge, Q rr Figure 6 Recovered charge, Q ra (5% chord) 1 1 4A T j =125 C 3A 2A 1A Recovered charge - Q rr (µc) 1 4A 3A 2A 1A Recovered charge - Q ra, 5% chord (µc) T j =125 C 1 1 1 1 1 di/dt (A/µs) 1 1 1 1 1 di/dt (A/µs) Figure 7 Reverse recovery current, I rm Figure 8 Reverse recovery time, t rr (5% chord) 1. 1 T j =125 C T j =125 C Reverse recovery current - I rm (A) 1. 1. 4A 3A 2A 1A Reverse recovery time (5% chord) - t rr (µs) 1 4A 3A 2A 1A 1. 1 1 1 1 di/dt (A/µs) 1 1 1 1 1 di/dt (A/µs) Data Sheet. Types N3533Z#14 to N3533Z#22 Page 6 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Figure 9 On-state current vs. Power dissipation Double Side Cooled (Sine wave) Figure 1 On-state current vs. Heatsink temperature - Double Side Cooled (Sine wave) 1 9 8 9 12 18 15 125 Maximum forward dissipation (W) 7 6 5 4 3 3 6 Maximum permissable heatsink temperature ( C) 1 75 5 2 25 3 6 9 12 18 1 1 2 3 4 5 Mean forward current (A) (Whole cycle averaged) 1 2 3 4 5 Mean forward current (A) (Whole cycle averaged) Figure 11 On-state current vs. Power dissipation Double Side Cooled (Square wave) Figure 12 On-state current vs. Heatsink temperature - Double Side Cooled (Square wave) 1 15 9 8 125 Maximum forward dissipation (W) 7 6 5 4 3 d.c. 27 18 12 9 6 3 Maximum permissible heatsink temperature ( C) 1 75 5 3 6 9 12 18 27 d.c. 2 25 1 1 2 3 4 5 6 7 Mean Forward Current (A) (Whole Cycle Averaged) 1 2 3 4 5 6 7 Mean Forward Current (A) (Whole Cycle Averaged) Data Sheet. Types N3533Z#14 to N3533Z#22 Page 7 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Figure 13 On-state current vs. Power dissipation Single Side Cooled (Sine wave) 45 4 3 6 18 9 12 Figure 14 On-state current vs. Heatsink temperature - Single Side Cooled (Sine wave) 15 Maximum forward dissipation (W) 35 3 25 2 15 1 Maximum permissable heatsink temperature ( C) 125 1 75 5 5 25 3 6 9 12 18 5 1 15 2 25 3 Mean forward current (A) (Whole cycle averaged) 5 1 15 2 25 3 Mean forward current (A) (Whole cycle averaged) Figure 15 On-state current vs. Power dissipation Single Side Cooled (Square wave) Figure 16 On-state current vs. Heatsink temperature - Single Side Cooled (Square wave) 45 15 4 125 Maximum forward dissipation (W) 35 3 25 2 15 d.c. 27 18 12 9 6 3 Maximum permissible heatsink temperature ( C) 1 75 5 3 6 9 12 18 27 d.c. 1 25 5 5 1 15 2 25 3 35 Mean Forward Current (A) (Whole Cycle Averaged) 5 1 15 2 25 3 35 Mean Forward Current (A) (Whole Cycle Averaged) Data Sheet. Types N3533Z#14 to N3533Z#22 Page 8 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Figure 17 Maximum surge and I 2 t Ratings 1 1.E+9 Total peak half sine surge current (A) 1 1 I 2 t: V RRM 1V I 2 t: 6% V RRM I TSM : V RRM 1V I TSM : 6% V RRM 1.E+8 1.E+7 Maximum I 2 t (A 2 s) T j (initial) = 125 C 1 1 3 5 1 1 5 1 5 1 N3533Z#14-22 1.E+6 Duration of surge (ms) Duration of surge (cycles @ 5Hz) Data Sheet. Types N3533Z#14 to N3533Z#22 Page 9 of 1 September, 27
WESTCODE An IXYS Company Phase Control Thyristor types N3533Z#14 to N3533Z#22 Outline Drawing & Ordering Information 11A281 11A35 Outline option ZC and ZT Outline option ZD and ZV ORDERING INFORMATION (Please quote 1 digit code as below) N3533 Z# Fixed Type Code Outline code ZC = 37.7mm clamp height, ZT = 37.7mm clamp height, rupture rated ZD = 26mm clamp height, ZV = 26mm clamp height, rupture rated Order code: N3533ZD22 22V V RRM, 26mm clamp height capsule. Voltage code V DRM/1 14-22 Fixed turn-off time code IXYS Semiconductor GmbH Edisonstraße 15 D-68623 Lampertheim Tel: +49 626 53- Fax: +49 626 53-627 E-mail: marcom@ixys.de IXYS Corporation 354 Bassett Street Santa Clara CA 9554 USA Tel: +1 (48) 982 7 Fax: +1 (48) 496 67 E-mail: sales@ixys.net WESTCODE An IXYS Company www.westcode.com www.ixys.net Westcode Semiconductors Ltd PO Box 57 Chippenham Wiltshire SN15 1JL Tel: +44 ()1249 444524 Fax: +44 ()1249 659448 E-mail: WSL.sales@westcode,com Westcode Semiconductors Inc 327 Cherry Avenue Long Beach CA 987 USA Tel: +1 (562) 595 6971 Fax: +1 (562) 595 8182 E-mail: WSI.sales@westcode.com The information contained herein is confidential and is protected by Copyright. The information may not be used or disclosed except with the written permission of and in the manner permitted by the proprietors Westcode Semiconductors Ltd. Westcode Semiconductors Ltd. In the interest of product improvement, Westcode reserves the right to change specifications at any time without prior notice. Devices with a suffix code (2-letter or letter/digit/letter combination) added to their generic code are not necessarily subject to the conditions and limits contained in this report. Data Sheet. Types N3533Z#14 to N3533Z#22 Page 1 of 1 September, 27