SPLIT TYPE ROO AIR CONDITIONER CEILING WALL type INVERTER odels Indoor unit AWHZLBC AWHZLBC Outdoor unit AOHZLBC AOHZLBC CONTENTS SPECIFICATIONS.................... OUTLINE AND DIENSIONS.......... REFRIGERANT SYSTE DIAGRA.... CIRCUIT DIAGRA.................. INDOOR PCB CIRCUIT DIAGRA..... OUTDOOR PCB CIRCUIT DIAGRA... ERROR CONTENTS................. DISASSEBLY ILLUSTRATION....... PARTS LIST.......................
SPECIFICATIONS TYPE INDOOR UNIT OUTDOOR UNIT COOLING CAPACITY HEATING CAPACITY Cooling and Heat-pump heating AWHZLBC AWHZLBC AOHZLBC AOHZLBC. kw. kw.0 kw. kw REFRIGERANT CHARGE (RA) Pipe Length m,0 g FULL CHARGE AOUNT 0 m,0 g ADDITIONAL REFRIGERANT 0 g / m AX PIPE LENGTH 0 m ELECTRICAL DATA POWER SUPPLY RUNNING CURRENT INPUT WATTS 0 V 0 Hz COOLING HEATING. A. A. A. A COOLING.0 kw. kw HEATING. kw. kw E.E.R. COOLING HEATING. kw/kw. kw/kw. kw/kw. kw/kw OISTURE REOVAL. L/hr. L/hr AIR CIRCULATION-HiGH COPRESSOR TYPE DISCRIINATION REFRIGERANT FAN OTOR POWER SOURCE COOLING HEATING RA 0 m/hr 0 m/hr Hermetic type, Inverter, Three phase Induction motor, Rotary 0-0 - 0,0 g 0 V INDOOR UNIT ( cool / heat ) OUTDOOR UNIT ( cool / heat ) HIGH HIGH-SPEED ED-SPEED LOW-SPEED QUIET SUPER-QUIET HIGH HIGH-SPEED,0 r.p.m. /,0 r.p.m.,0 r.p.m. /,0 r.p.m.,0 r.p.m. /,0 r.p.m.,00 r.p.m. /,0 r.p.m. 0 r.p.m. /,000 r.p.m. 0 r.p.m. / 0 r.p.m. / 0 r.p.m. 0 / 00 r.p.m. 0 / 0 r.p.m. 0 / 0 r.p.m. DIENSIONS and WEIGHT INDOOR UNIT OUTDOOR UNIT INDOOR UNIT OUTDOOR UNIT NOISE LEVEL H x W x D H x W x D GROSS / NET GROSS / NET 0 x x mm x 0 x 00 mm kg /. kg kg / kg HIGH db / db db / db HIGH-SPEED db / db db / db INDOOR UNIT ( cool / heat ) ED-SPEED LOW-SPEED db / db db / db db / db db / db QUIET db / db db / db SUPER QUIET db / db db / db OUTDOOR UNIT ( cool / heat ) HIGH db / db db / 0 db HIGH-SPEED db / db db / db Note : Noise was measured in accordance with JIS standards, Japan. "HIGH" means when ability measurement 00.0.0
DIENSIONS odels : AWHZLBC, AWHZLBC (Unit : mm) 00 0,000 0 0 odels : AOHZLBC, AOHZLBC 0 0 0 0 0 0 00 00.0.0
REFRIGERANT SYSTE DIAGRA odels : AWHZLBC / AOHZLBC AWHZLBC / AOHZLBC uffler -Way Valve Heat exchanger ( INDOOR ) Heat exchanger B ( INDOOR ) -Way Valve uffler Compressor Receiver -Way Valve Accumulator Heat exchanger ( OUTDOOR ) Strainer Strainer Pulse motor valve Cooling Heating Liquid pipe :. mm Gas pipe :. mm 00.0.0
INDOOR UNIT OUTDOOR UNIT CIRCUIT DIAGRA 00.0.0 BROW GREEN PURPLE GRAY GREEN PURPLE CN0 CN CN W W W W W W T0 T0 CN CN00 CN0 CN CN0 T0 T0 CN00 CN + - N P I O N L L CN0 CN0 CN0 T0 P N T0 D0 + - DISCHARGE TEP. THERISTOR PIPE TEP. THERISTOR OUTDOOR TEP. THERISTOR FUSE 0A-0V TERINAL N L -WAY VALVE EXPANSION VALVE FAN OTOR PV WV F CN00 CN00 R S C (U) (W) (V) C COPRESSOR T0 W T0 V T0 U CHOKE COIL ACTIVE FILTER ODURE CONTROLLER PCB ASSY TRANSISTOR PCB ASSY PURPLE GRAY GREEN GREEN / GRAY CN0 CN0 CN0 CN00 CN0 CN0 CN0 CN CN CN CN CN CN CN CN CN CN CN CN0 0 0 TERAL FUSE N L TERAL FUSE TERAL FUSE POWER RELAY SWITCH (LEFT) SWITCH (RIGHT) AIR FILTER (LEFT) AIR FILTER (RIGHT) T T POWER SOURCE TERINAL TEST ROO TEPERATURE THERISTOR PIPE TEPERATURE THERISTOR F DIFFUSER LOUVER Z LOUVER U RIGHT-LEFT LOUVER CONNECTOR () CONNECTOR () CONNECTOR () CONNECTOR () UV-LED UNIT RECEIVER PCB W CONTROLLER PCB INDICATOR PCB CONNECTOR BOARD
INDOOR PCB CIRCUIT DIAGRA odels : AWHZLBC AWHZLBC CN JB- CN P-SCN GRAY HUIDITY SENSOR PHR- V I N DO RHU-A GND PIPE TEPERATURE THERISTOR TERINAL N THERAL FUSE POWER SOURCE AC0-0V 0 / Hz CN P-SAN ROO TEPERATURE THERISTOR OUTDOOR UNIT L T 00 T 00 K CN BB-PASK CN JB- RECEIVER PCB ASSY K0DS-000HSE-SO UV-LED UNIT RH- TEST CN JB- CN CN JC- CN JC- RJW- CN0 JB- CN0 JB- CONNECTOR PCB K0DS-000HSE-CNO CN0 BB-XASK CN00 BB-XASK CN0 JB- CN0 JB- ZHR- CLEAN FILTER-R LIIT SWITCH-R BB-XASK ZHR- BB-XASK CLEAN FILTER-L LIIT SWITCH-L F.. FAN OTOR NH CONTROLLER PCB ASSY AWHZLBC : K0DS-000HSE-F AWHZLBC : K0DS-00HSE-F CN S (-) B-XARK CN JZ- CN JZ- 0 RJW-0 0 GREEN PURPLE GRAY ZHR- ZHR- ZHR- ZHR- LOUVER-U ( UP / DOWN ) LOUVER-Z ( UP / DOWN ) LOUVER ( RIGHT / LEFT ) DIFFUSER CN0 SB-PASK JB- CN0 CN0 SB-PH INDICATOR PCB ASSY K0DU-000HSD-DO 00.0.0
odels : AWHZLBC AWHZLBC CONTROLLER PCB ASSY AWHZLBC : K0DS-000HSE-F AWHZLBC : K0DS-00HSE-F CONTROLLER PCB RECIVER PCB ANUAL AUTE SWITCH 00.0.0
INDICATOR PCB odels : AWHZLBC AWHZLBC 00.0.0
OUTDOOR PCB CIRCUIT DIAGRA odels : AOHZLBC AOHZLBC INVERTER ASSEBLY AOHZLBC : EZ00CHUE AOHZLBC : EZ00DHUE POWER SOURCE AC0V / 0Hz F0 0A-0V TERINAL HP-T0--L POWER POWER SELIAL FAN OTOR EXPANSION VALVE EI FILTER ZCAT-00 F.. -WAY VALVE DISCHARGE TEPERATURE THERISTOR HEAT EXCHANGE TEPERATURE THERISTOR UL AWG UL AWG UL AWG EI FILTER ZCAT-0 UL AWG GREEN EARTH W B ( A- ) W B ( B- ) W B ( D- ) W B ( C- ) CN00 BH ( -. ) B-XASK--A ( H- ) CN00 BHP-VH-B-C ( F- ) CN00 BHB-XARK--A ( I- ) CN0 BHB-XH-Y ( K- ) CN BHB-XH-R ( K- ) T ( B- ) T ( A- ) DVB0 + - + CHOCK COIL L L ACTP SACT0F EI FILTER ZCAT0-0 CN P N N I O W UL AWG W UL AWG PURPLE W0 UL0 AWG UL0 AWG UL0 AWG UL0 AWG CONTROLLER PCB ASSY AOHZLBC : K0AD-000HUE-C AOHZLBC : K0AD-00HUE-C T ( A- ) T ( B- ) W ( A- ) W ( B- ) CN0 BH (.B ) -XAKK ( F- ) CN00 BHB-XASK--A ( E- ) CN0 BHB-XAKK--A ( I- ) CN BHB-XASK--A ( H- ) CN BHB-XH- ( K- ) UL AWG UL AWG W0 UL0 AWG GREEN PURPLE GRAY W0 UL0 AWG W0 UL0 AWG T0 ( C- ) T0 ( C- ) CN0 BH (.0 ) B-PASK- ( F- ) CN0 BHB-PASK- ( F- ) CN0 BHB-XH- ( C- ) TRANSISTOR PCB ASSY K0DP-000HUD-TRO U T0 ( C- ) V T0 ( C- ) W T0 ( C- ) COPRESSOR C.. PEX-F EI FILTER ZCAT-0 OUTDOOR TEPERATURE THERISTOR CN BHB-XAEK ( K- ) 00.0.0
odels : AOHZLBC AOHZLBC CONTROLLER PCB ASSY AOHZLBC : K0AD-000HUE-C AOHZLBC : K0AD-00HUE-C PS-P J0 AWHZLBC AWHZLBC 00.0.0
ERROR CONTENTS Error Operation LED Display Timer LED flash Error Serial signal (reverse) error, at operation start up Serial signal error Off flash flash Serial signal (reverse) error, during operation Serial signal (forward) error, at operation start up flash Serial signal (forward) error, during operation Indoor unit thermistor error flash flash flash Indoor temperature thermistor open / short Heat exchanger middle thermistor open / short flash Discharge thermistor open / short Outdoor unit thermistor error flash flash Heat exchanger thermistor open flash Outdoor temperature thermistor open / short flash Forced automatic SW welded Indoor unit control error flash flash ain relay welded flash Power interruption error flash Current trip error Outdoor unit control error flash flash flash CT abnormal Compressor location detection error flash Outdoor unit fan drive system abnormal Indoor fan motor error flash flash flash Abnormal lock Abnormal rotation Refrigerant cycle error flash flash flash Discharge Temperature abnormal Cooling high pressure abnormal rise Optional function error flash flash flash Active filter abnormal (first time) Active filter abnormal (second time) odel error Blinking Blinking odel error 00.0.0
DISASSEBLY ILLUSTRATION odels : AWHZLBC AWHZLBC 00.0.0
0 0 0 0 0 00.0.0
odels : AOHZLBC AOHZLBC 0 0 00.0.0
PARTS LIST INDOOR UNIT Ref. No. Description AWHZLBC Part No. AWHZLBC Ord. Q'ty Air Filter 0 Dust Box Assy 0 Front Panel Assy 0 Open Panel Assy 00 Top Grill 0 Top Cover 0 Under Cover 00 Casing Assy 0 Louver U Assy 0 Louver U 0 Louver Frame 0 Spring EL 00 Louver Z 0 Spring F 0 Diffuser U 0 Diffuser Z 0 Spring C 0 Casing Cover F 0 0 Casing Cover B 0 Casing Cover L 0 Casing Cover R 0 Bushing-A 00 Louver Cam 0000 Tension A 00 Spring Holder 0 Gear A 000 Drain Hose Assy 0 Drain Cap Assy 0000 0 Evaporator Assy 0 Evaporator Assy B 0 Evaporator Assy C 0 Joint Pipe Assy 0 Senser Case 0 Sensor Cover 0 0 otor Cover 00 Crossflow Fan Assy 000 Bearing C Assy 00 Control Box 000 Controll Cover 000 Receiver Case 0 Cord Clamp 00 Evaporator Holder R 0 Evaporator Holder L 0 0 Rear Bracket 0 Controller PCB Assy 000 Power Cord Assy 000 Display Assy 000 Fan otor Assy 00 Stepping otor U 00 Stepping otor Z 0000 Connector w/wire S 0 0 UV Unit Assy 0 Remote Controller Assy 0 Gear Box Assy 00 --- Room Temp. Thermistor 000 --- Pipe Temp. Thermistor 000 --- Fuse A 0000 --- Relay 00 0 0 0 00 0 0 00 0 0 0 0 00 0 0 0 0 0 0 0 0 0 00 0000 00 0 000 0 0000 0 0 0 0 0 0 00 000 00 000 000 0 00 0 0 0 000 000 000 00 00 0000 0 0 0 00 000 000 0000 00 00.0.0 When you order parts, please make a photocopy of this page and fill the number of the parts in the "Order" column.
OUTDOOR UNIT Ref. No. Description AOHZLBC Part No. AOHZLBC Ord. Q'ty Top Panel Assy 000 Cabinet Sub Assy 000 Blow Grill 00 Cabinet Right Assy 00 Fan Ring 00 Grip 000 Switch Cover Assy 00 Protective Net 0 000 000 00 00 00 000 00 0 -way Valve 000 Pulse otor Valve Assy 0 Condenser Assy 000 Thermo Spring A 0 Thermo Spring 0000 Propeller Fan 000 otor Bracket 00 Separater 000 000 0 000 0 0000 000 00 000 Base Assy 00 -way Valve Assy 0 0 -way Valve Assy 00 Valve Bracket 000 Cord Clamp 0 Terminal P 00 Inverter PCB Assy 00 TR PCB Assy 00 00 0 00 000 0 00 00 00 ACTP 00 Fuse 00000 Fan otor 00 Compressor Assy 0 0 Discharge Thermistor 00 Heat Exchange Thermistor 000 Outdoor Temp. thermistor 00 Solenoid 000 00 00000 00 0 00 000 00 000 Expansion Valve Coil 0000 Choke coil 00 --- Emblem --- Discharge Pipe Assy 0 0000 00 0 00.0.0 When you order parts, please make a photocopy of this page and fill the number of the parts in the "Order" column.
STANDARD ACCESSORIES The following installation accessories are supplied. Use them as required. Name and Shape Q'ty Name and Shape Q'ty Wall hook bracket Drain pipe 000 0 Cloth tape Remote control unit 000 Tapping screw (big) 0 Battery 00000 Tapping screw (small) 0000 Remote control unit holder 00000 Seal A 0 0000 00.0.
0G