PERECT INE-UP, EST COST PERORMNCE T-000 Series MINI TERM MSS OWMETER OUTOOK T-000 MINI TERM MSS OWMETERS are designed and developed to offer the remote indication and control of gas flow process where glass tube purgemeters have been commonly used. T-000 MINI TERM MSS OWMETERS are very competitive in price and very compact in size and can be a good substitution for such glass tube purgemeters. New type in the mid to large diameter has been added to T-000 series. Different types of sensors cover all requirements for gas measurement. lso ll-in-one type panel mount convertors are ready for easy loop design. ETURES ow cost, igh performance igh accuracy Direct mass flow measurement using thermal theory ree from changes of pressure and temperature! No compensation required. Quick response 0.5sec. for % Easy maintenance No by-pass tube used. igh durability Newly designed sensing element offers high durability. Supporting instruments are ready. Wide range Min. 0 to /min(nor)., Max. 7m /h(nor). can be covered by one line. The piping layout can be freely made due to the short required straight run. PRODUCT INE-UP Different sensors and panel mount convertors are ready to choose Mass flowmeter ow price, Compact T-00 P Engineering plastic body T-00 S SCS casted body Standard type T- Stainless steel body, Mid to large connection types are available. T- Stainless steel body, ow pressure loss Outdoor use, Water tight housing T- Stainless steel body, Mid to large connection types are available T- Stainless steel body, ow pressure loss T-5 Stainless steel body, With indicator, Mid to large connection types are available Convertor TM-0 low rate, Totalizing, and alarm indication, nalog output, Totalizing pulse output, larm output OPERTION PRINCIPE Temperature detection sensor Ra and velocity detection sensor Rw are installed in the gas flow path of T-000 MINI-TERM MSS OWMETER. The internal electronics circuits keep the temperature gap between Rw (Tw) and Ra (Ta = Gas temp.) constant by supplying electric current I. The transferred heat from Ra to passed gas (Rw I ) is proportional to the mass flow rate of the gas to be measured which can be calculated from supplied corrent I. The detection principle is completely free from the change of gas pressure and the change of temperature. It is compensated by internal software and finally the measurement is totally independent of any operating conditions. The flow rate is calculated from supplied current I and output in the form of electric signal. I Ra Ta Rw Tw O W
T-000 SERIES MINI-TERM MSS OW METER STNDRD SPECIICTION ND MODE CODE [up to 000/min(nor)] Model T-00 P/S T- T- Type Compact type Stainless steel body, Standard type Gas to be measured Scale range ll kinds of gases, except gases containing more than 0%(Vol.) of or e and mixture of or e and Cnm Min. 0 to /min(nor) Max. 0 to 0 /min(nor) mb. and Gas temp. 0 to 60 C [0 to C for T-000P (Poly-acethal resin body)] Gas press. -0.07 to.0 MPa ccuracy ±.0%.S. Temp. change effect Within ±0.%.S. / C Press. change effect Within ±0.%.S. /0. MPa Rangeability : 0 Gas contact part material Tube Sensor Seal Stainless steel body, Water tight housing ousing material S resin IP0 equ. (Indoor use) DC IP65 equ. (Water tight) Process connection Power supply/ Output T-00 P : Poly-cethal, P, SUS6 T-00 S : SCS, P, SUS6 T-00 P : Rc/ T-00 S : Rc/ or OD/ SW SUS6[SUS6 and P (T- )] Combination of SUS6, Glass, PT and CTE KM or CR Min. 0 to /min(nor) Max. 0 to 000 /min(nor) T- : Rc/ OD/, /8, / SW 5, 0, 5, JIS0K lange T- : Rc/, /8 OD/, /8, / SW 5, 0, 5, JIS0K lange T- : Rc/8, / OD/8, /, / SW 5, 0, 5, JIS0K lange T- : Rc/8, /, / OD/8, /, / SW 5, 0, 5, JIS0K lange T- 0 ± V DC or ±5 V DC, + m, -0 m/0 to 5 V DC (oad resistance:more than 5kΩ) T- V DC ±0%, +m/ to 0 m DC (oad resistance:ess than Ω) Electric connection T-00 - - low range /min(nor) up to 0 Power supply/ 0 ± V DC(5V)0 to 5 V DC Output V DC/ to 0 m DC P Poly-cethal ody material S SCS 00 0 to 0 0 to 0 0 to 5 080 0 to 8 00 0 to 0 Scale range 0 to 5 /min (nor) 0 to 0 0 0 to 0 0 to 800 0 to 80 0 0 to 00 0 to 0 P Rc thread rating S Swagelok* size 0/(8) *Swagelok connection is available only for T-00 S type. Exclusive cable with connector T- - - low range /min (nor) Power supply/ 0 Output 00 0 0 080 00 0 0 Scale range 800 0 /min (nor) 5 0 5 0 60 80 0 rating size P S (Choose the connection size from the above-mentioned process connection.) 0 0 6 0 8 6 up to 0 up to up to 0 up to 000 ± V DC(5V)0 to 5 V DC V DC/ to 0 m DC 0 to 0 to 0 to 5 0 to 8 0 to 0 0 to 5 T- 0 to 0 0 to 0 to 0 to 80 0 to 00 0 to 0 0 to 0 to T- 0 to 0 to 0 0 to 00 T- 0 to 0 0 to 600 0 to 800 T- 0 to 000 Rc thread Swagelok JIS0K lange /(8) /8(0) /(5) /(0) (5) G/, M screw terminal T- - - low range /min (nor) Power supply/ 0 Output 00 0 0 080 00 0 0 Scale range 800 0 /min (nor) 5 0 5 0 60 80 0 P rating S size (Choose the connection size from the above-mentioned process connection.) 0 0 6 0 8 6 up to 0 up to up to 0 up to 000 ± V DC(5V)0 to 5 V DC V DC/ to 0 m DC 0 to 0 to 0 to 5 0 to 8 0 to 0 0 to 5 T- 0 to 0 0 to 0 to 0 to 80 0 to 00 0 to 0 0 to 0 to T- 0 to 0 to 0 0 to 00 T- 0 to 0 0 to 600 0 to 800 T- 0 to 000 Rc thread Swagelok JIS0K lange /(8) /8(0) /(5) /(0) (5) CO., TD. TG-ES65-7E
T-000 SERIES MINI-TERM MSS OW METER T- T- T-5 ow pressure loss, Indoor use ow pressure loss, Water tight type ll kinds of gases, except gases containing more than 0%(Vol.) of or e and mixture of or e and Cnm Min. 0 to /min(nor) Min. 0 to /min(nor) Max. 0 to 000 /min(nor) Max. 0 to 000 /min(nor) 0 to 60 C -0.07 to.0 MPa ±.0%.S. Within ±0.%.S. / C Within ±0.%.S. /0. MPa : 0 With indicator, Water tight type S resin IP0 equ. (Indoor use) SUS6 T- : Rc/ or 5JIS0K lange T- : Rc/ or 0JIS0K lange T- : Rc or 5JIS0K lange Combination of SUS6, Glass, PT and CTE KM or CR DC IP65 equ. (Water tight) T- 0 ± V DC or ±5 V DC, + m, -0 m/0 to 5 V DC (oad resistance:more than 5kΩ) T- V DC ±0%, + m/ to 0 m DC (oad resistance:ess than Ω) SUS6 [SUS6 and P (T-5)] C IP65 equ. (Water tight) T-5: Rc/, /8, / OD/, /8, / SW 5, 0, 5, JIS0K lange T-5: Rc/, /8, / OD/, /8, / SW 5, 0, 5, JIS0K lange T-5: Rc/8, / OD/8, / SW 5, 0, 5, JIS0K lange T-5: Rc/8, /, / OD/8, /, / SW 5, 0, 5, JIS0K lange 85 to 0 V C, V to 0 m DC (oad resistance:ess than Ω) Exclusive cable with connector T- - - low range /min(nor) Power supply/ 0 Output 5 0 5 Scale range 0 /min (nor) 60 80 0 rating P size (Choose the connection size from the above-mentioned process connection.) up to up to 0 up to 000 ± V DC(5V) 0 to 5 V DC V DC/ to 0 m DC 0 to 0 to T- 0 to 0 to 0 0 to 00 T- 0 to 0 0 to 600 0 to 800 T- 0 to 000 Rc thread JIS0K lange 08/(5) /(0) 6 (5) *T- is recommended for scale range smaller than 0/min(nor). *Required straight run for upstream is 5D and downstream is 0D. Installation of the pipe is the same connection of flowmeter. T- low range /min(nor) Power supply/ Output Scale range /min (nor) rating G/, M screw terminal - - 0 5 0 5 0 60 80 0 size (Choose the connection size from the above-mentioned process connection.) up to up to 0 up to 000 ± V DC(5V) 0 to 5 V DC V DC/ to 0 m DC 0 to 0 to 0 to 0 to 0 0 to 00 0 to 0 0 to 600 0 to 800 0 to 000 P Rc thread JIS0K lange 08/(5) /(0) 6 (5) T- T- T- *T- is recommended for scale range smaller than 0/min(nor). *Required straight run for upstream is 5D and downstream is 0D. Installation of the pipe is the same connection of flowmeter. T-5 - low range /min(nor) Power supply/ Output 00 0 0 080 00 0 0 Scale range 800 0 /min (nor) 5 0 5 0 60 80 0 rating -G/, M screw terminal size (Choose the connection size from the above-mentioned process connection.) - P S 0 0 6 0 8 6 up to 0 up to up to 0 up to 000 85 to 0 V C/ to 0 m DC 0 to 0 to 0 to 5 0 to 8 0 to 0 0 to 5 0 to 0 0 to 0 to 0 to 80 0 to 00 0 to 0 0 to 0 to 0 to 0 to 0 0 to 00 0 to 0 0 to 600 0 to 800 0 to 000 Rc thread Swagelok JIS0K lange /(8) /8(0) /(5) /(0) (5) T-5 T-5 T-5 T-5 TG-ES65-7E CO., TD.
OW RTE OW RTE OW RTE OW RTE OW RTE OW RTE T-000 SERIES MINI-TERM MSS OW METER DIMENSION ND WEIGT T-000 Compact type [T-000P.T-000S] Rc screw connection / T-000P pprox.0g T-000S pprox.g MINI-TERM MSS OWMETER T-000 OW MG.No. OW 6 7 SW connection (pprox.g for T-000S) -SW MINI-TERM MSS OWMETER T-000 OW MG.No. OW RTE 6 7 -Md -Md, Rating /SW 0 T-0 Stainless steel body, Standard type [T-0] Rc screw connection (pprox.g) 0 SW connection (pprox.5g) /8SW /SW T- 6mm 8 MINI-TERM MSS OWMETER MINI-TERM MSS OWMETER / MG. NO. OW.5 -SW MG. NO. OW.5, Rating /SW 7 /8SW /SW lange connection (pprox..9kg) MINI-TERM MSS OWMETER MG. NO. OW.5 [Rc, SW and lange connection] Mounting dimension (ottom face) 0 5 6 6 -Md 80 [T-0] Rc screw connection (pprox.6g) SW connection (pprox.70g) MINI-TERM MSS OWMETER MINI-TERM MSS OWMETER MG. NO. MG.NO. OW 77 -SW OW 77, Rating /SW 7 6 6 /8SW /SW lange connection (pprox..0kg) MINI-TERM MSS OWMETER MG. NO. OW 6 77 [Rc, SW and lange connection] Mounting dimension (ottom face) 0 6 6 -Md 80 CO., TD. TG-ES65-7E
NO. MG.NO. OW RTE OW RTE NO. NO. OW RTE OW RTE NO. NO. OW RTE OW RTE T-000 SERIES MINI-TERM MSS OW METER [T-] Rc screw connection (pprox.kg) SW connection (pprox..kg) MINI-TERM MSS OWMETER MG. OW 8 9 MINI-TERM MSS OWMETER MG. OW 8 9 [lange connection] Mounting dimension (ottom face) 0 7 -Md6 MINI-TERM MSS OWMETER OW 6.5 6 5 MINI-TERM MSS OWMETER MG., Rating -SW OW /8SW 9 /SW 97.5 /SW 06 [Rc and SW connection] Mounting dimension (ottom face) -Md6 5 MINI-TERM MSS OWMETER MG. -SW OW 8, Rating /8SW 68 9 /SW 7 /SW 8 [Rc and SW connection] Mounting dimension (ottom face) -Md6 lange connection (pprox..5kg).5 [T-0] Rc screw connection (pprox..5kg) SW connection (pprox..8kg) lange connection (pprox..kg) MINI-TERM MSS OWMETER MG. OW [lange connection] Mounting dimension (ottom face) 8 9 -Md6 TG-ES65-7E CO., TD. 5
OW RTE MSS OWMETER MG. NO. OW OW RTE T-000 SERIES MINI-TERM MSS OW METER T- Stainless steel body, Water tight housing type Rc screw connection SW connection 5 G/ -SW 5 [Rc, SW and lange connection] Mounting dimension (ottom face) C -Md6 Size C Mass (kg) Model / /8 / / /8 / / /8 / /8 / / 59 6 66 7 8 88 9 96 6 08 58 9 0 58 5 5 58.5 60 65 5 5.... T- T- T- T- lange connection () Size Rating C Mass (kg) Model 5 0 5 JIS 0K (R) () 96 00 9 5. T- 5 0 5 JIS 0K (R) () 5 0 5 JIS 0K (R) () 5 0 5 JIS 0K (R) () 08 5 7 5 5 9 9.5 8.5.5 5.7 6. T- T- T- T-0 ow pressure loss, Indoor use type Rc screw connection lange connection MINI-TERM MSS OWMETER MG.NO. OW MINI-TERM () [Rc, and lange connection] Mounting dimension (ottom face) C -Md6 Size / / 5 0 5 Rating Rc connection lange connection JIS0K (R) () 5 60 5 7 5 8 5 5 5 5 8 99 6 67.5 7 80 0 80 0 C Mass (kg).5.5 5. 5. 8.5.8.8 5.8 Model T- T- T-0 T- T- T-0 T- 6mm 6 CO., TD. TG-ES65-7E
T-000 SERIES MINI-TERM MSS OW METER T-00 ow pressure loss, Water tight type Rc screw connection lange connection 5 G/ 5 [Rc, and lange connection] Mounting dimension (ottom face) C -Md6 T-0 With indicator, Water tight type Size / / Rating Rc connection 5 60 5 5 58 65 7 80 0 C.5 5 5 Mass (kg)..8.9 Model T- T- T- 5 0 5 lange connection JIS0K (R) () 5 7 5 8 5 5 9.5 7 80 0 8.5.. 6. T- T- T- Rc screw connection 06 SW connection 86 -G/ -SW [Rc, and connection] Mounting dimension (ottom face) C -Md6 lange connection Size / /8 / / /8 / / /8 / /8 / / 59 6 66 7 8 88 9 96 6 C 08 58 9 0 58 5 5 58.5 60 65 5 5 Mass (kg).6.7.9.6 Model T-5 T-5 T-5 T-5 Size 5 0 5 5 0 5 5 0 5 5 0 5 Rating JIS 0K (R) () JIS 0K (R) () JIS 0K (R) () JIS 0K (R) () 96 08 5 C Mass (kg) 00 9 5.9 9 5.0 7 9 8.5 6. 5 5.5 6.9 Model T-5 T-5 T-5 T-5 TG-ES65-7E CO., TD. 7
T-000 SERIES MINI-TERM MSS OW METER STNDRD SPECIICTION ND MODE CODE [Middle to arge connection type] Model T-5 T-5 T-55 Type Standard type Water tight housing Gas to be measured mb. and Gas temp. Gas press. ccuracy Temp. change effect Press. change effect Gas contact part material Rangeability Tube Sensor Seal ll kinds of gases, except gases containing more than 0%(Vol.) of or e and mixture of or e and Cnm 0 to 60 C -0.07 to.0 MPa ±.0%.S. Within ±0.%.S./ C Within ±0.%.S. /0. MPa ousing material S resin IP0 equ. (Indoor use) DC IP65 equ. (Water tight) C IP65 equ. (Water tight) Process connection : 0 SUS6 or SUS Combination of SUS6, Glass, PT and CTE (SCS) SUS KM or CR Rc female screw ( to ) JIS0K lange (5 to 80) With indicator, Water tight type Power supply / Output Electric connection T- 0 ± V DC or ±5 V DC, + m, -0 m/0 to 5 V DC (oad resistance: More than 5kΩ) T- V DC ±0%, + m/ to 0 m DC (oad resistance: ess than Ω) 85 to 0 V C, V to 0 m DC (oad resistance: ess than Ω) Exclusive cable with connector G/, M screw terminal -G/, M screw terminal T- - - T- - - T-5 - - up to 7m /h(nor) up to 7m low /h(nor) up to 7m low /h(nor) low 5 (Refer to the following 5 (Refer to the following 5 (Refer to the following range range range Scale range table.) Scale range table.) Scale range table.) Power supply/ 0 ± V DC(5V) 0 to 5 V DC Power supply/ 0 ± V DC(5V) 0 to 5 V DC Power supply/ 85 to 0 V C/ Output V DC/ to 0 m DC V DC/ to 0 m DC Output Output to 0 m DC Scale range C low rate rating Scale range C low rate rating Scale range C low rate rating SUS (vailable SUS (vailable SUS (vailable only for flange only for flange only for flange Material connection) Material connection) Material connection) SUS6 SUS6 SUS6 6 (vailable for all 6 (vailable for all 6 (vailable for all models) models) models) P Rc thread ( to ) P Rc thread ( to ) P Rc thread ( to ) rating JIS0K lange rating JIS0K lange rating JIS0K lange (5 to 80) (5 to 80) (5 to 80) 5 (5) 5 (5) 5 (5) size -/ () size -/ () size -/ () (Choose the connection size 0-/ from the following ull scale table.) 65-/ 80 *ull scale=() 0 C m /h(nor) (Ex.) m /h(nor) 0 00m /h(nor) 0 7m /h(nor) (0) () (65) (80) (Choose the connection size 0-/ from the following ull scale table.) 65-/ 80 *ull scale=() 0 C m /h(nor) (Ex.) m /h(nor) 0 00m /h(nor) 0 7m /h(nor) (0) () (65) (80) (Choose the connection size 0-/ from the following ull scale table.) 65-/ 80 *ull scale=() 0 C m /h(nor) (Ex.) m /h(nor) 0 00m /h(nor) 0 7m /h(nor) (0) () (65) (80) ull scale according to connection 5 0 65 80 Gas Min. Max. Min. Max. Min. Max. Min. Max. Min. Max. Min. Max. IR 65 0 0 50 7 N 65 0 0 50 7 O 65 0 0 50 7 CO 65 0 0 50 7 CO 65 0 0 50 7 r 65 0 0 50 7 N 57 9 68 5 06 67 95 5 C 5 5 00 60 0 60 60 C6 7 6 8 78 79 9 79 0 C 5 69 9 6 7 0 9 7 5 C0 6 60 6 80 56 8 88 08 8 0 m /h(nor) 5 7 7 98 69 57 08 55 57 68 8 CO., TD. TG-ES65-7E
OW RTE OW RTE MSS OWMETER MG. NO. OW OW RTE MSS OWMETER MG. NO. OW RTE OW T-000 SERIES MINI-TERM MSS OW METER T-5 6mm T-5 Standard type Rc screw connection (Rc) Width across flat of joints: 6 (pprox..9kg) Rc screw connection (Rc-/ to Rc) MINI-TERM MSS OWMETER MG.NO. OW (68) () MINI-TERM D 95 Size -/ -/ Rating Rc connection (Width across flat) D 5 55 60 79 60 65 85 Mass (kg).8.9.6 lange connection (5) (pprox..6kg) lange connection ( to 80) MINI-TERM MSS OWMETER MG.NO. OW (68) () MINI-TERM 95 T-5 Water tight housing type Size Rating Mass (kg) 0 65 80 lange connection JIS0K (R) () 5 79 85 9 00.. 5.9 8.0 9.0 Rc screw connection (Rc) Width across flat of joints: 6 (pprox..kg) G/ 5 G/ Rc screw connection (Rc-/ to Rc) 5 () D () 5 95 Size Rating (Width across flat) D -/ -/ Rc connection 5 5 5 60 55 60 60 65 Mass (kg)... TG-ES65-7E CO., TD. 9
T-000 SERIES MINI-TERM MSS OW METER lange connection (5) (pprox..kg) lange connection ( to 80) () () 95 Size 0 65 80 Rating lange connection JIS0K (R) () 5 5 5 60 68 Mass (kg).6.8 5.9 8.5 9.5 T-55 With indicator, Water tight type Rc screw connection (Rc) Width across flat of joints: 6 (pprox..9kg) 06 Rc screw connection (Rc-/ to Rc) 06 () Size -/ -/ Rating Rc connection 5 5 5 60 (Width across flat) 55 60 D 60 65 Mass (kg).8.9.6 () () 86 () 86 -G/ -G/ D 5 95 lange connection (5) (pprox..6kg) lange connection ( to 80) 95 Size 0 65 80 Rating lange connection JIS0K (R) () 5 5 5 60 68 Mass (kg) 5. 5. 6. 9.0 0.0 0 CO., TD. TG-ES65-7E
T-000 SERIES MINI-TERM MSS OW METER PRECUTIONS OR INSTTION Required straight run (d: diameter) PRESSURE OSS (The following graphic chart is data in case of air.) Model T-00 P T-00 S T- T- T- T- T-5 T- T- T- T- T-5 T- T- T- T- T- T- T-5 Upstream 5d (*, *) 5d (*, *) 5d (*) 5d (*) Downstream 5d (*, *) 5d (*, *) (*) (*) Press. loss [kpa] 0 9 8 7 6 5 T-00 S/00 P/ / /5 Primary pressure TM 0 C 0/min (nor) /min (nor) 0/min (nor) 000/min (nor) T-5 T-5 T-5 0 0 00 0 00 0 600 0 800 0 000 T-55 5d (*, *) 5d (*, *) low rate [/min (nor)] (*) The piping different from the diameter of flowmeter is up to ± size. Make the piping after installing the required straight run in the same diameter as the flowmeter. T- / ow press. loss type Primary pressure TM 0 C /min (nor) 0/min (nor) 000/min (nor).5 Press. loss [kpa] (*) Make use of Rc screw fittings less than Sch. 80. (*) Make use of the piping in the same diameter as that of the flowmeter. efore installing the flowmeter onto process piping, flush and clean the whole piping. Install valves downstream if any. Use the shielded cable for wiring and do not locate it near to power supply line etc. to avoid the electric noise. Confirm the arrow mark on the tube which indicates the flow direction. In case of T-5 (With indicator type), the flow direction and configuration are as follows. Specify the flow direction at the time of an order. 0.5 0 5 0 00 0 00 0 600 0 800 0 000 low rate [/min (nor)] T-5 /5 /55 Middle to arge connection type Primary pressure TM 0 C 5 0 65 80 0 999 999 orizontal installation orizontal installation Press. loss [kpa] 5 0 low direction eft to Right low direction Right to eft 5 It is recommended to provide bypass piping for maintenance. 0 0 00 0 00 0 600 0 800 low rate [m /h (nor)] TG-ES65-7E CO., TD.
T-000 SERIES MINI-TERM MSS OW METER TM-0 MINI CONVERTOR UNIT OUTINE TM-0 MINI CONVERTOR UNIT is power supply and indication unit which is used in combination with Tokyo Keiso s T-0, T-000, T- 00, T-6000 and (-) EP-T-00 series MSS OWMETERS. ll necessary functions of power supply to the detectors and scaled flow indication is provided in DIN 7mm compact housing. dditionally, either totalization (with scaled pulse output) of flow or high and low alarm is available for total gas volume management or stable gases supply applications. lso, analog re-output function ( to 0 m DC or 0 to 5 V DC) is provided as standard for further connection to recorders and/or process control loop. STNDRD SPECIICTION OW RTE INDICTION Indication : y digit CD (mm height) ccuracy : ±0.%.S.± last digit additional to detector accuracy nalog re-output (lternative) : a) to 0 m DC Max.load 0Ω : b) 0 to 5 V DC Min.load 00 kω Output accuracy : ±0.%.S. additional to detector accuracy TOTIZTION UNCTION Indication : y 7 digit CD (6mm height) Scaled pulse : Output Open collector Rating V DC, 0 m Max. Pulse width 00 ms (ixed) Pulse rate Equal to counter increments Indication accuracy : ±0.%.S. additional to detector accuracy Scaling factor : 8,000 c/h (Max.) Total re-set : y manual push button or short-circuiting of terminal OW CUT : Standard % (reely programmable) Corresponding function : low rate indication, low rate output, Totalization indication, and Scaled pulse output RM UNCTION larm indication : Red color ED (The light is turned on in operation) larm output : SPST NO (Make contact) or NC (reak contact) (The contact will be opened without power supply.) Contact rating : 5 V C, 0./ V DC, Setting point : points (igh and ow) Setting range : 0 to 00% of span Setting : ield adjustable through front panel key ysteresis width :.0%.S.(ixed) NOG INPUT (lternative) : a) to 0 m DC Input resistance Ω b) 0 to 5 V DC Input resistance kω OTER UNCTION Multi-data : Max.8 different data can be programmed. (Channel selection by front panel key) inearise function (Option) : a) ourth formula multiplier method : b) Extraction of square-root multiplier method Data back up : Total count and operation parameters are memorized by EEROM for 0 years. EXTERN POWER SUPPY : ± V DC, +m, -m OTER SPECIICTION Power supply Power consumption : 5V : 85 to V C /60z Electrical connection : Pin terminal mbient temp : 0 to C (To be free from condensation) Withstand voltage : Power supply to Earth terminal 0 V C, min. Insulation resistance : Power supply to Earth terminal More than 0MΩ (0 V DC) Construction ousing material Weight MODE CODE TM - nalog Input nalog Output larm Output Input & Output characteristics Standard Option Option : Indoor use (IP0 equ.) : S resin containing glass fiber : pprox.g R to 0 m DC 0 to 5 V DC to 0 m DC 0 to 5 V DC : NO, : NO : igh : NC, : NC : ow : NO, : NC NO : Make contact : NC, : NO NC : reak contact inear ourth formula multiplier method Extraction of square-root multiplier method PPICE OWMETERS ND EXCUSIVE CE pplicable flowmeters T-0/000/00/0 T-/00 T-/60 M-000/00 (Option) Cable code SC-MM SC-M SC-M SC-M Cable length m : Standard 00m (Max.) CO., TD. TG-ES65-7E
T-000 SERIES MINI-TERM MSS OW METER DIMENSIONS PNE CUT ND MOUNT DISTNCE More than +0.7 67 0 +0.7 67 0 7 TM-0 CONVERTOR 5.5 06 7 7 More than 00 Note) Recommending mount panel in to 5mm thickness. RONT PNE TERMIN igh alarm TM-0 CONVERTOR UNIT:(nor) Indication Upper : low rate ower : Totalization ow alarm I /h m /h /min Unit 5 6 7 8 9 0 5 6 7 8 9 0 m O MODE PUSE OUT NOG OUT DC POWER TO METER NOG IN Up Down Shift NO WIRING (C) (E) RESET 5 (+) (-) +V COM -V (+) to 0 m DC 0 to 5 V DC IG RM 6 7 OW RM 8.G. 9 0 (-) to 0 m DC 0 to 5 V DC POWER MODE Mode 5 6 7 NO NC NO NC 8 9 0 85 to V C WIRING No. Non - use (C) Pulse (E) Output No. Non - use Reset Cable wiring when mass flow meter is used and model change is made from TM-000 to TM-0 should cut the cable of the connector socket part inserted in a converter, and strip cable coating about 7mm and carry out connection as follows. 5 6 7 (+) nalog ( ) Output (+V) (COM) DC power to meter 5 6 7 igh alarm output ow alarm output 6 7 8 9 0 +V COM -V (+) (-) Red Green Yellow White lack 8 9 0 ( V) (+) nalog ( ) Input 8 9 0. G. C power supply Detector Exclusive cable TG-ES65-7E CO., TD.
T-000 SERIES MINI-TERM MSS OW METER PPICTIONS or 0 to 5 V DC Output version In case standard power supply unit is used; In case TM-0 series converter unit is used; T-000P, T-000S, T- 0, T- 0 T-000P, T-000S, T- 0, T- 0 SC-MC cable SC-MM cable ± V DC or ±5 V DC 0 to 5 V DC To control loop T-000 Power supply T-000 5C cable 0 to 5 V DC To control loop T- 0, T- 0 SC-M cable nalog output Scaled pulse output and alarm output ± V DC or ±5 V DC Power supply TM- C or cable with exclusive connector, to 0 m DC Output version or M screw terminal, to 0 m DC Output version T-00P, T-00S, T-, T- T-, T- SC-MP cable C cable to 0 m DC To control loop to 0 m DC To control loop T-00 Power supply V DC Power supply V DC or T5 series (With indicator) version C cable to 0 m DC To control loop nalog output 999 Scaled pulse output CE TERMIN Y TE SIDE O DETECTOR SC-MP.9 5.8 Red Green White lack C 0.mm 5.6 C TM- and alarm output C SC-MM. 5.8 Red Green Yellow White 5 lack 5C 0.mm 6 SC-M Power supply Output signal of flow rate (0 to 5 V DC) +V COM -V + - Red Green Yellow White 5 lack 5C 0.mm 6 CO., TD. TG-ES65-7E
T-000 SERIES MINI-TERM MSS OW METER OREDRING INORMTION Specify the following for order /inquiry MINI-TERM MSS OW METER Model Gas to be measured Pressure Temperature ull scale size type low direction (T-5 ) T- - - Max. Nor. Min. MPa kpa Max. Nor. Min. C /h (nor) /min (nor) m /h (nor) / (8) /8 (0) / (5) / (0) (5) -/ () -/ (0) () (65) (80) Rc thread Swagelok JIS0K lange VCR (Option) eft to Right Right to eft SUPPORTING INSTRUMENTS Mini converter Exclusive cable TM- SC-MM SC-M * Specification is subject to change without notice. ead Office : Shiba Toho uilding, 7 Shibakoen, Minato-ku, Tokyo 05 8558 Tel : +8-65 (KEY) ; ax : +8-9 e-mail : overseas.sales@tokyokeiso.co.jp ; UR : http://www.tokyokeiso.co.jp TG-ES65-7E CO., TD. 5